苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
高温后再生水泥砂浆抗压强度试验研究
Experimental Study on Compressive Strength of Recycled Cement Mortar after High Temperature
2016年第11期
再生水泥砂浆;立方体抗压强度;取代率;再生细骨料;质量损失率
Recycled cement mortar; Cube compressive strength; Replacement rate; Recycled fine aggregate; Mass lose rate
2016年第11期
1000-4637(2016)11-82-05
国家自然科学基金项目(41172317);2016年安全生产重大事故防治关键技术科技项目(henan-0006-2016AQ);焦作市2015年科技计划项目;2015年度大学生创新创业训练计划项目(201510460005、201510460011)
张向冈1,2,汪 昉2,杨健辉1,2,陈 真2,吴 帆2
1. 河南理工大学 生态建筑与环境构建河南省工程实验室,焦作 454000; 2. 河南理工大学 土木工程学院,焦作 454000

张向冈1,2,汪 昉2,杨健辉1,2,陈 真2,吴 帆2

浏览量:
1000
摘 要:以再生细骨料取代率和温度作为影响参数,设计并制作了45个标准立方体试块进行抗压强度试验。观察了试块的破坏过程和破坏形态,实测了试块的极限抗压强度,分析了不同温度下立方体抗压强度与再生细骨料取代率的关系以及不同取代率下立方体抗压强度与温度的关系,讨论了影响参数对于立方体抗压强度的影响规律。结果表明:再生水泥砂浆的破坏过程和形态与天然水泥砂浆相似;当温度达到400℃时,试块无爆裂现象,但试块的颜色变成了暗粉红色;随着再生细骨料的增加,试块质量损失率增大;在恒温3h的条件下,不同的温度对立方体试块抗压强度的影响规律并不明显。 Abstract: Taking the replacement rate of recycled fine aggregate and temperature as the affect parameters, 45 standard cube test blocks were designed and produced to carry out compressive strength test. The failure process and failure mode of test blocks were observed. The limit of the cube compressive strength of test blocks were measured, the relations between cube compressive strength and recycled fine aggregate under different temperatures and the relations between cube compressive strength and temperatures under different replacement rates were also analyzed, the influence law that the parameters made on the cube compressive strength was discussed. The results showed that, the failure process and the failure mode of recycled fine aggregate cement mortar and the failure process and the failure mode of nature is similar; when the temperature reached 400℃, the block has no burst phenomenon, but the color of block turned into a dark pink; with the increase of recycled fine aggregate, the mass lose rate of block increase; the influence law that different temperature making on cube compressive strength of test block is not obvious when temperature keeps same for 3h.
英文名 : Experimental Study on Compressive Strength of Recycled Cement Mortar after High Temperature
刊期 : 2016年第11期
关键词 : 再生水泥砂浆;立方体抗压强度;取代率;再生细骨料;质量损失率
Key words : Recycled cement mortar; Cube compressive strength; Replacement rate; Recycled fine aggregate; Mass lose rate
刊期 : 2016年第11期
DOI :
文章编号 : 1000-4637(2016)11-82-05
基金项目 : 国家自然科学基金项目(41172317);2016年安全生产重大事故防治关键技术科技项目(henan-0006-2016AQ);焦作市2015年科技计划项目;2015年度大学生创新创业训练计划项目(201510460005、201510460011)
作者 : 张向冈1,2,汪 昉2,杨健辉1,2,陈 真2,吴 帆2
单位 : 1. 河南理工大学 生态建筑与环境构建河南省工程实验室,焦作 454000; 2. 河南理工大学 土木工程学院,焦作 454000

张向冈1,2,汪 昉2,杨健辉1,2,陈 真2,吴 帆2

摘要
参数
结论
参考文献
引用本文

摘   要:以再生细骨料取代率和温度作为影响参数,设计并制作了45个标准立方体试块进行抗压强度试验。观察了试块的破坏过程和破坏形态,实测了试块的极限抗压强度,分析了不同温度下立方体抗压强度与再生细骨料取代率的关系以及不同取代率下立方体抗压强度与温度的关系,讨论了影响参数对于立方体抗压强度的影响规律。结果表明:再生水泥砂浆的破坏过程和形态与天然水泥砂浆相似;当温度达到400℃时,试块无爆裂现象,但试块的颜色变成了暗粉红色;随着再生细骨料的增加,试块质量损失率增大;在恒温3h的条件下,不同的温度对立方体试块抗压强度的影响规律并不明显。

Abstract: Taking the replacement rate of recycled fine aggregate and temperature as the affect parameters, 45 standard cube test blocks were designed and produced to carry out compressive strength test. The failure process and failure mode of test blocks were observed. The limit of the cube compressive strength of test blocks were measured, the relations between cube compressive strength and recycled fine aggregate under different temperatures and the relations between cube compressive strength and temperatures under different replacement rates were also analyzed, the influence law that the parameters made on the cube compressive strength was discussed. The results showed that, the failure process and the failure mode of recycled fine aggregate cement mortar and the failure process and the failure mode of nature is similar; when the temperature reached 400℃, the block has no burst phenomenon, but the color of block turned into a dark pink; with the increase of recycled fine aggregate, the mass lose rate of block increase; the influence law that different temperature making on cube compressive strength of test block is not obvious when temperature keeps same for 3h.

关键词:
再生水泥砂浆;立方体抗压强度;取代率;再生细骨料;质量损失率
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)随着温度的不断升高,再生细骨料水泥砂浆试块在初期的表面特征变化不明显,但当温度升高到400℃时,试块颜色由灰色逐渐变成暗粉红色,但试块均没有出现爆裂现象。
(2)再生水泥砂浆试块和普通水泥砂浆试块的破坏过程和破坏形态基本相似,呈现两个正倒相连的四角锥。
(3)随着再生细骨料取代率的增加,再生水泥砂浆试块质量损失率增大;不同取代率下,400℃时的试块比200℃时试块的质量损失率有不同程度的增加;当取代率为100%时,质量损失率增加幅度最多,高达10.30%。
(4)在20~400℃范围内,且恒温3h的条件下,随着温度的升高,再生水泥砂浆试块的抗压强度规律性不明显。
[1] 赵军,刘秋霞,林立清,等.大城市建筑垃圾产生特征演变及比较[J].中南大学学报:自然科学版,2013,44(4):1297-1304.
[2] Monalisa B,Bhattacharyya S K,Minocha A K, et al. Recycled aggregate from C&D waste & its use in concrete-A break through towards sustainability in construction sector: A review[J].Construction and Building Materials,2014,68:501-516.
[3] 刘数华,阎培渝.再生骨料混凝土的力学性能[J].武汉大学学报:工学版,2010,43(1):85-101.
[4] 周文娟,陈家珑,路宏波.绿色再生砂浆试验研究[J].武汉理工大学学报,2009,31(7):15-18.
[5] 肖建庄.再生混凝土[M].北京:中国建筑工业出版社,2008.
[6] 张向冈,陈宗平,薛建阳.再生混凝土的物理与力学性能试验研究[J].硅酸盐通报,2015,34(6):1684-1688.
[7] 徐亦冬,周士琼,肖佳.再生混凝土骨料试验研究[J].建筑材料学报,2004,7(4):447-450.
[8] 杨子胜,王爱勤,祝彦知.建筑垃圾再生砂浆的力学性能研究[J].中原工学院学报,2015,26(3):72-75.
[9] 徐明,王韬,陈忠范.高温后再生砂浆单轴受压应力-应变关系试验研究[J].建筑结构学报,2015,36(2):151-157.
[10] 李丹,何锐,王帅,等.PVA纤维增强水泥基复合材料高温性能研究[J].硅酸盐通报,2015,34(6):1604-1609.
[11] 张美香,罗忠涛,包文忠,等.恒温变湿下粉煤灰矿粉双掺对水泥砂浆体积变形的影响[J].混凝土与水泥制品,2013(3):22-24.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州