苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
PVA纤维改性磷酸盐水泥材料的研究
Study on PVA Fiber Modified Phosphate Cement-based Materials
2016年第12期
PVA纤维;磷酸镁水泥;纤维增强水泥基复合材料;抗弯曲强度
PVA fiber; MPC; Fiber reinforced cement based composite; Bending strength
2016年第12期
1000-4637(2016)12-44-04
国家自然科学基金项目(51172146、51472163)
孙 晨,丁 铸
深圳大学土木工程学院,广东省滨海土木工程耐久性重点实验室,250022

孙 晨,丁 铸

浏览量:
1000
摘 要:为了探究PVA纤维对磷酸镁水泥性能的影响,制备了不同掺量PVA纤维复合MPC,测试其抗压、抗折强度、弯曲性能,并用X射线三维重构显微镜(XCT)分析了微观结构。研究结果表明,PVA纤维的加入对磷酸镁水泥抗折性能有显著的提高,但是对抗压强度影响不大;PVA纤维的加入对于弯曲性能有较好的改善,延性显著提高,显示出明显的弯曲硬化特点,可以有效改善磷酸镁水泥的脆性破坏特征。微观分析发现,PVA纤维在基体中成均匀乱向分散,有利于阻止裂缝的发展。 Abstract: In order to study the effects of PVA fiber on properties of MPC, composite MPC with different dosage of PVA fiber was prepared to test the compressive strength, flexural strength, flexural properties, and the microstructure was analyzed by using XCT. The results showed that the addition of PVA fiber has a significant improvement on the flexural strength of MPC, but it has little effect on the strength of resistance. The addition of PVA fiber has a good improvement in flexural properties, and the ductility is significantly improved, which shows obvious bending hardening characteristics and can effectively improve the brittle failure characteristics of MPC. The microscopic analysis show that the PVA fiber is evenly distributed in uniform chaos, which can prevent the development of cracks.
英文名 : Study on PVA Fiber Modified Phosphate Cement-based Materials
刊期 : 2016年第12期
关键词 : PVA纤维;磷酸镁水泥;纤维增强水泥基复合材料;抗弯曲强度
Key words : PVA fiber; MPC; Fiber reinforced cement based composite; Bending strength
刊期 : 2016年第12期
DOI :
文章编号 : 1000-4637(2016)12-44-04
基金项目 : 国家自然科学基金项目(51172146、51472163)
作者 : 孙 晨,丁 铸
单位 : 深圳大学土木工程学院,广东省滨海土木工程耐久性重点实验室,250022

孙 晨,丁 铸

摘要
参数
结论
参考文献
引用本文

摘   要:为了探究PVA纤维对磷酸镁水泥性能的影响,制备了不同掺量PVA纤维复合MPC,测试其抗压、抗折强度、弯曲性能,并用X射线三维重构显微镜(XCT)分析了微观结构。研究结果表明,PVA纤维的加入对磷酸镁水泥抗折性能有显著的提高,但是对抗压强度影响不大;PVA纤维的加入对于弯曲性能有较好的改善,延性显著提高,显示出明显的弯曲硬化特点,可以有效改善磷酸镁水泥的脆性破坏特征。微观分析发现,PVA纤维在基体中成均匀乱向分散,有利于阻止裂缝的发展。

Abstract: In order to study the effects of PVA fiber on properties of MPC, composite MPC with different dosage of PVA fiber was prepared to test the compressive strength, flexural strength, flexural properties, and the microstructure was analyzed by using XCT. The results showed that the addition of PVA fiber has a significant improvement on the flexural strength of MPC, but it has little effect on the strength of resistance. The addition of PVA fiber has a good improvement in flexural properties, and the ductility is significantly improved, which shows obvious bending hardening characteristics and can effectively improve the brittle failure characteristics of MPC. The microscopic analysis show that the PVA fiber is evenly distributed in uniform chaos, which can prevent the development of cracks.

关键词:
PVA纤维;磷酸镁水泥;纤维增强水泥基复合材料;抗弯曲强度
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)一定掺量范围内,PVA纤维的掺入对MPC的抗折强度有显著提高,特别是对早期抗折强度的提高更为明显,但对抗压强度影响不大。
(2)PVA纤维的掺加可以有效地提高MPC试件的弯曲性能,试件开裂后有明显的弯曲硬化特点,说明PVA纤维的掺入提高了试件的延性,改善了脆性破坏的特点,提高了MPC材料的断裂延性,但PVA纤维的掺加对其开裂模式没有明显影响。
(3)XCT微观分析发现,对于磷酸镁水泥,PVA纤维掺量为1.0%时,纤维在基体中呈现良好的乱向分散状态,起到了良好的“桥联”作用,阻止了裂缝的发展。
[1] 赖振宇,钱觉时,卢忠远,等.原料及配比对磷酸镁水泥性能影响的研究[J].武汉理工大学学报,2011,33(10):16-20.
[2] ZDing, Z J Li.Effect of aggregates and water contents on the properties of magnesium phosphosilicate cement[J].Cement & Concrete Composites,2005,27(1):11-8.
[3] 丁铸,邢峰,李宗津.高早强磷硅酸盐水泥修复性能的研究[J].工业建筑,2008,38(9):77-79.
[4] 常远,史才军,杨楠,等.磷酸镁水泥基材料耐久性研究进展[J].硅酸盐学报,2014,42(4):487-493.
[5] YLi,J Sun,B Chen.Experimental study of magnesia and M/P ratio influencing properties of magnesium phosphate cement [J]. Construction & Building Materials,2014,65(13):177-183.
[6] 孙道胜,孙鹏,王爱国,等.磷酸镁水泥的研究与发展前景[J].材料导报A:综述篇,2013,27(5):70-75.
[7] C K Chau,F Qiao,Z J Li.Microstructure of magnesium potassium phosphatecement[J]. Construction & Building Mate rials,2011,25(6):2911-2917.
[8] PFrantzis,RBaggott.Bond betweed reinforcing steel fibres and magnesium phosphate/calcium aluminate binders[J]. Cement and Concrete Research,2000,22:187-192.
[9] G Fischer,V C Li.Effect Of Matrix Ductility On Defor mation Behavior Of Steel Reinforced ECC Flexural Members Under Reversed Cyclic Loading Conditions[J]. ACI Structural Journal,2002,99(6):781-790.
[10] 杨建明,钱春香,荀勇,等.玻璃纤维增强磷酸镁水泥复合材料的耐久性[J].建筑材料学报,2009(5):590-594.
[11] R Krüger,JM Seitz,A Ewald.Strong and tough magnesium wire reinforced phosphate cement composites for load-bearing bone replacement[J]. Journal of the Mechanical Behavior of Biomedical Materials,2013,20(4):36-44.
[12] Jean Pera,Jean Ambroise. Fiber -reinforced Magnesia-phosphate CementComposites for Rapid Repair[J].Cement and Concrete Composites,1998,20:31-39.
[13] 李悦,孙佳,施同飞.纤维改性磷酸镁水泥性能的研究[J].河北工业大学学报,2014,43(6):1-4.
[14] 林水东,程贤延,林志忠.PP和PVA纤维对水泥砂浆抗裂和强度性能的影响[J].混凝土与水泥制品,2005(1):43-45.
[15] S Wang, VC Li. Polyvinyl alcohol reinforced engineered cem entitious composites[J]. Material Design and Performances,2003.
[16] VC Li,S Wang. High early strength engineered cementitious composites[J].Aci Materials Journal,2006(2):103.
[17] VC Li.Interface Tailoring for Strain-hardening PVA-ECC[J].Aci Materials Journal,2011,99:463-472.
[18] 李艳,梁兴文,刘泽军.高性能生态型建筑材料PVA-ECC的实验研究[J].工业建筑,2011(10):97-102.
[19] 郑玉国,崔元东,王伟男,等. PVA-ECC的最优配比及力学性能试验研究[J].河南工程学院学报,2014(2):70-72.
 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州