苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
加热改性再生混凝土粗骨料试验研究
Experimental Investigation of Recycle Coarse Aggregate Modified by Heating Method
2015年第10期
加热;再生粗骨料;改性;正交试验
Heating method; Recycled coarse aggregate; Improving performance; Orthogonal test
2015年第10期
1000-4637(2015)10-06-05
绵阳市科技计划项目(12G031-4);四川省循环经济研究中心项目(XHJJ-0918);西南科技大学研究生创新基金(14YCX091)
苏 燕,古 松,常晓蕾,李金星
西南科技大学土木工程与建筑学院,绵阳 621010

苏 燕,古 松,常晓蕾,李金星

浏览量:
1000
摘 要:采用加热法对简单破碎再生混凝土粗骨料进行正交试验改性研究。加热工艺的控制参数为加热温度、恒温时间,对加热后再生粗骨料表面附着砂浆的剥离方式采用混凝土振动台,控制参数为混凝土振动台振动时间。试验测试了改性前后再生骨料的吸水率、表观密度、压碎指标,采用极差分析法对正交试验结果进行分析。结果表明,加热温度可明显改善再生粗骨料性能,而增加恒温时间及振动台振动时间对提高再生粗骨料性能效果不显著。 Abstract: Heating method was adopted to improve the performance of simple crushed recycled coarse aggregate and the experiment method was the orthogonal test. Control parameters in heating process were the heating temperature and constant temperature time, and in the process of wiping out the surface mortar on heated recycled aggregate, the concrete vibrating table was used, the controlling parameter for this process was the vibration time. The rate of water absorption, apparent density, crush index of recycled coarse aggregate before and after the improving process were tested, and the range analysis results of orthogonal test show that controlling heating temperature can significantly improve the performance of recycled coarse aggregate, and the effect by increasing the time of constant temperature and vibration time to improve the recycled coarse aggregate performance is not significant.
英文名 : Experimental Investigation of Recycle Coarse Aggregate Modified by Heating Method
刊期 : 2015年第10期
关键词 : 加热;再生粗骨料;改性;正交试验
Key words : Heating method; Recycled coarse aggregate; Improving performance; Orthogonal test
刊期 : 2015年第10期
DOI :
文章编号 : 1000-4637(2015)10-06-05
基金项目 : 绵阳市科技计划项目(12G031-4);四川省循环经济研究中心项目(XHJJ-0918);西南科技大学研究生创新基金(14YCX091)
作者 : 苏 燕,古 松,常晓蕾,李金星
单位 : 西南科技大学土木工程与建筑学院,绵阳 621010

苏 燕,古 松,常晓蕾,李金星

摘要
参数
结论
参考文献
引用本文

摘   要:采用加热法对简单破碎再生混凝土粗骨料进行正交试验改性研究。加热工艺的控制参数为加热温度、恒温时间,对加热后再生粗骨料表面附着砂浆的剥离方式采用混凝土振动台,控制参数为混凝土振动台振动时间。试验测试了改性前后再生骨料的吸水率、表观密度、压碎指标,采用极差分析法对正交试验结果进行分析。结果表明,加热温度可明显改善再生粗骨料性能,而增加恒温时间及振动台振动时间对提高再生粗骨料性能效果不显著。

Abstract: Heating method was adopted to improve the performance of simple crushed recycled coarse aggregate and the experiment method was the orthogonal test. Control parameters in heating process were the heating temperature and constant temperature time, and in the process of wiping out the surface mortar on heated recycled aggregate, the concrete vibrating table was used, the controlling parameter for this process was the vibration time. The rate of water absorption, apparent density, crush index of recycled coarse aggregate before and after the improving process were tested, and the range analysis results of orthogonal test show that controlling heating temperature can significantly improve the performance of recycled coarse aggregate, and the effect by increasing the time of constant temperature and vibration time to improve the recycled coarse aggregate performance is not significant.

关键词:
加热;再生粗骨料;改性;正交试验
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)加热改性再生粗骨料过程中,控制适当加热温度可明显改善再生粗骨料物理力学性能。当加热温度为500℃时,再生骨料性能明显改善。温度为700℃时,再生骨料受高温破坏,骨料性能下降。
(2)加热工艺中增加恒温时间对提高再生骨料性能有一定效果,但效果不显著。在加热工艺中应根据再生粗骨料状态及数量恰当地选用。
(3)混凝土振动台振动可有效去除加热后再生骨料表面的疏松砂浆,但混凝土振动台振动时间因素的选取对再生粗骨料物理力学性能影响不显著。
(4)根据极差分析结果,所取再生骨料的加热改性再生粗骨料工艺中,选取加热温度500℃,恒温时间30min,混凝土振动台振动时间15min为宜。
[1] 王瑞敏,王林秀.中国建筑垃圾现状分析及发展前景[J].中国城市经济,2011(5):178-179.
[2] Poon C.S., Kou S.C., Lam L. Use of recycled aggregates in molded concrete bricks and blocks[J]. Const and Build Mat,2002,16(5): 281-89.
[3] 古松,苏燕,胡宏骏.再生混凝土基本力学性能及开发研究[J].混凝土,2015(4):90-94.
[4] RYU J S. An experimental study on the effect of recycled aggregate on concrete properties[J]. Magazine of Concrete Research, 2003, 54(1):7-12.
[5] 朋改非,黄艳竹,张九峰.骨料缺陷对再生混凝土力学性能的影响[J].建筑材料学报,2012,15(1):80-84.
[6] 杜婷,李惠强,吴贤国.混凝土再生骨料强化试验研究[J].新型建筑材料,2000(3):6-8.
[7] 朱亚光,徐培蓁.硅烷与PVA对再生混凝土粗骨料改性试验研究[J].混凝土,2015(3):93-95.
[8] 李秋义,李云霞,朱崇绩.颗粒整形对再生粗骨料性能的影响[J].材料科学与工艺,2005(6):579-582.
[9] 李秋义,王志伟,李云霞.加热研磨法制备高品质再生骨料的研究[G]//智能与绿色建筑文集.北京:中国建筑工业出版社,2005: 883-889.
[10] 李清海,姚燕,孙蓓,等.高温对水泥砂浆强度的影响及机理分析[J]. 建筑材料学报,2008,11(6):699-703.
[11] 水中和,玄东兴,曹蓓蓓.热-机械力分离制备高品质再生骨料的研究[J].混凝土, 2006(12): 60-62.
[12] Y.F.Fu, Y.L.Wong, C.A.Tang, et al. Thermal induced stress and associated cracking in cement-based composite at elevated tempera-tures-Part II:Thermal cracking around multiple inclusion[J]. Cem.Concr. Compos.,2004,26:113-120.
[13] 刘瑞江,张业旺,闻崇炜.正交试验设计和分析方法研究[J]. 实验技术与管理, 2010, 27(9):52-55.
[14] 董娟.混凝土振动搅拌技术的理论分析及相关装置的研究[D]. 西安:西安建筑科技大学,2009.
[15] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会.GB/T 25177—2010 混凝土用再生粗骨料[S].北京: 中国标准出版社,2011.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州