苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
高吸水树脂对混凝土性能的影响研究
Influence Research of Super Absorbent Polymers (SAP) on Performance of Concrete
2015年第11期
内养护;高吸水树脂;强度;开裂;孔结构
Internal curing; Super absorbent polymers(SAP); Strength; Cracking; Pore structure
2015年第11期
1000-4637(2015)11-01-07
国家国际科技合作专项项目(2014DFR81000);二秦高速公路科技示范工程项目(H-2014-1);内蒙古自治区交通运输厅建设科技项目(NJ-2013-31)
魏晓帆1,2,柯国炬1,侯子义2,田 波1
1.交通运输部公路科学研究院,北京 100088;2.河北工业大学土木工程学院,天津 300401

魏晓帆1,2,柯国炬1,侯子义2,田 波1

浏览量:
1000
摘 要:通过水泥砂浆流动度试验、水泥胶砂试件强度试验、水泥胶砂试件干缩试验、混凝土强度试验、混凝土孔结构分析和混凝土面板早期诱导开裂试验,系统研究了高吸水树脂对水泥胶砂及混凝土性能的影响。结果表明,高吸水树脂内养护对水泥胶砂试件流动性影响与其吸水性能有重要关系,但在混凝土中则并不明显;高吸水树脂对水泥胶砂试件早期干缩有很好的抑制作用,后期干缩抑制效果不明显;高吸水树脂对混凝土后期强度降低不大,对混凝土孔结构总孔隙率影响不明显,高吸水树脂增大了混凝土大孔的体积,稍微降低了气孔间距系数;掺吸水树脂的混凝土要控制早期水分蒸发,避免发生塑性收缩开裂。 Abstract: The influence of two different super absorbent polymers as an internal curing agent on the properties of the cement paste and concrete are studied by investigating the cement mortar flow test, cement mortar strength test, cement mortar specimens shrinkage test, strength test of concrete, concrete pore structure analysis and the concrete early induced cracking test. The experiment results show that influence of SAP on the fluidity of cement mortar has important relationship with its water absorption property, but it is not obvious for the concrete. The SAP can counteract the early shrinkage of cement paste effectively while it is not obvious for the later age. The influence of SAP on the concrete strength and air content are not evident, the spacing factor is attenuated. Early water evaporation must be controlled for concrete with SAP to avoid plastic cracking.
英文名 : Influence Research of Super Absorbent Polymers (SAP) on Performance of Concrete
刊期 : 2015年第11期
关键词 : 内养护;高吸水树脂;强度;开裂;孔结构
Key words : Internal curing; Super absorbent polymers(SAP); Strength; Cracking; Pore structure
刊期 : 2015年第11期
DOI :
文章编号 : 1000-4637(2015)11-01-07
基金项目 : 国家国际科技合作专项项目(2014DFR81000);二秦高速公路科技示范工程项目(H-2014-1);内蒙古自治区交通运输厅建设科技项目(NJ-2013-31)
作者 : 魏晓帆1,2,柯国炬1,侯子义2,田 波1
单位 : 1.交通运输部公路科学研究院,北京 100088;2.河北工业大学土木工程学院,天津 300401

魏晓帆1,2,柯国炬1,侯子义2,田 波1

摘要
参数
结论
参考文献
引用本文

摘   要:通过水泥砂浆流动度试验、水泥胶砂试件强度试验、水泥胶砂试件干缩试验、混凝土强度试验、混凝土孔结构分析和混凝土面板早期诱导开裂试验,系统研究了高吸水树脂对水泥胶砂及混凝土性能的影响。结果表明,高吸水树脂内养护对水泥胶砂试件流动性影响与其吸水性能有重要关系,但在混凝土中则并不明显;高吸水树脂对水泥胶砂试件早期干缩有很好的抑制作用,后期干缩抑制效果不明显;高吸水树脂对混凝土后期强度降低不大,对混凝土孔结构总孔隙率影响不明显,高吸水树脂增大了混凝土大孔的体积,稍微降低了气孔间距系数;掺吸水树脂的混凝土要控制早期水分蒸发,避免发生塑性收缩开裂。

 Abstract: The influence of two different super absorbent polymers as an internal curing agent on the properties of the cement paste and concrete are studied by investigating the cement mortar flow test, cement mortar strength test, cement mortar specimens shrinkage test, strength test of concrete, concrete pore structure analysis and the concrete early induced cracking test. The experiment results show that influence of SAP on the fluidity of cement mortar has important relationship with its water absorption property, but it is not obvious for the concrete. The SAP can counteract the early shrinkage of cement paste effectively while it is not obvious for the later age. The influence of SAP on the concrete strength and air content are not evident, the spacing factor is attenuated. Early water evaporation must be controlled for concrete with SAP to avoid plastic cracking. 

关键词:
内养护;高吸水树脂;强度;开裂;孔结构
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)低水灰比中SAP对水泥胶砂试件流动性和流动性损失的影响与其吸收速率和饱和吸收率密切相关,高水灰比因水分充足表现并不明显。加入预吸水SAP可以减少水泥砂浆工作性损失,对保持流动性是一种很好的新途径。掺加SAP对新拌混凝土工作性影响的强弱与其吸水速率和倍率大小并无明显对应关系。在外加剂和引入水量不变的情况下,干掺SAP可以降低新拌混凝土工作性,这种效果潜在用途是可以尝试在喷射混凝土中不使用速凝剂来增加铺设层厚度。
(2)水灰比相同时,掺加SAP对于水泥胶砂试件抗折和抗压强度均有降低,但对于低水灰比早期(7d)抗压强度和抗折强度的影响并不明显。SAP内养护的混凝土早期(7d)抗压强度显著降低,后期(28d)强度降低幅度明显减少。
(3)掺加SAP使混凝土含气量影响不大,略微提高了混凝土的气孔间距系数。SAP内养护使得胶孔比略微降低,同时提高了大孔体积,掺加预吸水SAP增加了低水灰比混凝土后期水化程度,在多重因素的综合影响下降低了混凝土的强度。高吸水树脂的粒径对于混凝土的孔结构有一定影响,粒径更大可以在坍缩后留下更大的气孔。坍缩后留下的与粒径形状一致的球形孔洞提供了通过改变高吸水树脂颗粒的形状控制混凝土内部孔形状的可能性,同时说明了所使用的高吸水树脂的粒径和形状应该根据实际工程需要进行选择。
(4)高吸水树脂内养护虽然可以减少混凝土的干缩和自收缩,但是由于其在混凝土拌合后继续吸收混凝土中自由水,使得混凝土在干燥多风环境下早期的塑性收缩更加明显,因此在干燥多风地区使用高吸水树脂进行内养护时需要特别注重早期的覆盖保护和外部养护。
[1] 吴中伟,廉慧珍.高性能混凝土[M].北京:中国铁道出版社,1999: 8-10.
[2] RILEM TC—ICC2003, Internal curing of concrete[S]. RILEM Techical Committee.
[3] 王立霞.混凝土内养护技术国内外研究进展[J].混凝土,2014(5):30-34.
[4] 孔祥明,张珍林.高吸水性树脂对高强混凝土自收缩的减缩机理[J].硅酸盐学报,2014,42(2):150-155.
[5] V. Mechtcherine, C. Schroefl, M. Gorges. Effectiveness of various superabsorbent polymers (SAP) in mitigating autogenous shrinkage of cement-based materials[J]. Mechanics and Physics of Creep, Shrinkage, and Durability of Concrete.2012(1):324-331.
[6] 叶华,赵建青,张宇.吸水树脂水泥基材料自养护外加剂的研究[J].华南理工大学学报, 2003(11): 41.
[7] Kovler, K., Jensen, O. M.. “Internal curing of concrete. State-of-theart report of RILEM Technical Committee 196-ICC. RILEM Report 41”[MR].RILEM Publications, Bagneux, 2007:161.
[8] 张珍林.高吸水性树脂对高强混凝土早期减缩效果及机理研究[D].北京:清华大学, 2013:40-48.
[9] JESEN O M, HANSEN P F. Water-entrained cementbased materials-II:implementation and experimental results[J]. Cement and concrete research, 2002,32(6): 973-978.
[10] Horkay F,Tasaki I,Basser P. Effect of monovalent-divalent cation exchange on the swelling of polyacrylate hydrogels in physiological salt solutions[J]. Biomacromolecule, 2001, 2(1):195-199.
[11] Schrfl C,Mechtcherine V,Gorges M. Relation between the molecular structure and the efficiency of superabsorbent polymers (SAP) as concrete admixture to mitigate autogenous shrinkage[J]. Cement and Concrete Research,2012,42(6): 865-873.
[12] 吴季怀,林建明,魏月琳,等.高吸水保水材料[M].北京:化学工业出版社,2005:135-137.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州