苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
高铝煤矸石活化及在灌浆料中的应用研究
Activation of Coal Gangue with High Alumina and Its Application Study in Cement-based Grouts
2014年第1期
高铝煤矸石;热活化,灌浆料中应用
High alumina coal gangue; Thermal activation; Application in grouting material
2014年第1期
1000-4637(2014)01-90-04
杨飞华2,程海丽1,张 杰3
1.北方工业大学建筑学院,北京 100144;2.固废资源化利用与节能建材国家重点实验室, 北京 100041;3.中冶建筑研究总院有限公司,北京 100088

杨飞华2,程海丽1,张 杰3

浏览量:
1000
摘 要:以内蒙古某地高铝煤矸石为研究对象,采用胶砂强度法研究了其最佳热活化条件,并将活化后的煤矸石分别取代水泥和掺合料硅灰应用于水泥基灌浆料中。结果表明,该高铝煤矸石的最佳热活化温度为800℃;活化高铝煤矸石替代水泥基灌浆料中的水泥时,可使其流动度下降,但替代其掺合料硅灰时,可使其流动度增加;活化高铝煤矸石无论是替代灌浆料中的水泥还是硅灰,均可使灌浆料的凝结时间缩短;活化高铝煤矸石替代灌浆料中的水泥时,对初期强度不利,但7d后强度均有不同程度提高,活化高铝煤矸石替代灌浆料中的硅灰时,可提高其强度,取代率越大,提高幅度越大,完全取代效果最好。 Abstract: The heat-activated condition of high alumina coal gangue in Neimenggu is studied, and then, the activated coal gangue is used in grouting material to study the application effect. The result shows that the optimal calcining temperature of high alumina coal gangue is 800℃. The fluidity of the grouting material decreases when Portland cement is replaced by the activated coal gangue, but increases when silica fume is replaced. Adding the activated coal gangue can shorten the setting time of grouting material. The compressive strength of the grouting material enhances when silica fume is replaced by activated coal gangue powder, and the more the replacement ratio, the greater the strength; the compressive strength of grouting material enhances when cement is replaced by activated coal gangue powder after 7d,but decreases in1d.
英文名 : Activation of Coal Gangue with High Alumina and Its Application Study in Cement-based Grouts
刊期 : 2014年第1期
关键词 : 高铝煤矸石;热活化,灌浆料中应用
Key words : High alumina coal gangue; Thermal activation; Application in grouting material
刊期 : 2014年第1期
DOI :
文章编号 : 1000-4637(2014)01-90-04
基金项目 :
作者 : 杨飞华2,程海丽1,张 杰3
单位 : 1.北方工业大学建筑学院,北京 100144;2.固废资源化利用与节能建材国家重点实验室, 北京 100041;3.中冶建筑研究总院有限公司,北京 100088

杨飞华2,程海丽1,张 杰3

摘要
参数
结论
参考文献
引用本文

摘   要:以内蒙古某地高铝煤矸石为研究对象,采用胶砂强度法研究了其最佳热活化条件,并将活化后的煤矸石分别取代水泥和掺合料硅灰应用于水泥基灌浆料中。结果表明,该高铝煤矸石的最佳热活化温度为800℃;活化高铝煤矸石替代水泥基灌浆料中的水泥时,可使其流动度下降,但替代其掺合料硅灰时,可使其流动度增加;活化高铝煤矸石无论是替代灌浆料中的水泥还是硅灰,均可使灌浆料的凝结时间缩短;活化高铝煤矸石替代灌浆料中的水泥时,对初期强度不利,但7d后强度均有不同程度提高,活化高铝煤矸石替代灌浆料中的硅灰时,可提高其强度,取代率越大,提高幅度越大,完全取代效果最好。

Abstract: The heat-activated condition of high alumina coal gangue in Neimenggu is studied, and then, the activated coal gangue is used in grouting material to study the application effect. The result shows that the optimal calcining temperature of high alumina coal gangue is 800℃. The fluidity of the grouting material decreases when Portland cement is replaced by the activated coal gangue, but increases when silica fume is replaced. Adding the activated coal gangue can shorten the setting time of grouting material. The compressive strength of the grouting material enhances when silica fume is replaced by activated coal gangue powder, and the more the replacement ratio, the greater the strength; the compressive strength of grouting material enhances when cement is replaced by activated coal gangue powder after 7d,but decreases in1d.

关键词:
高铝煤矸石;热活化,灌浆料中应用
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)本试验用内蒙产高铝煤矸石的最佳热活化温度为800℃。
(2)热活化高铝煤矸石替代水泥基灌浆料中的水泥时,可使流动度下降,但替代其掺合料硅灰时,使流动度增加。
(3)热活化高铝煤矸石无论是替代灌浆料中的水泥还是掺合料硅灰,均可使灌浆料的的凝结时间有一定程度的缩短。
(4)热活化高铝煤矸石替代灌浆料中的水泥对初期强度不利,但7d后强度均有不同程度提高。热活化高铝煤矸石替代灌浆料中的掺合料硅灰时,可提高强度,取代率越大,提高幅度越大,完全取代时,强度提高幅度最大。
(5)从流动度、凝结时间和抗压强度三个方面综合看,热活化煤矸石取代灌浆料中的掺合料硅灰较取代水泥效果好。
[1] 张志勇,王春梅,曹会云.煤矸石综合利用的现状[J].山东煤炭科技,2006(6).
[2] 韩红光,刘海龙,崔莉.煤矸石资源化利用关键问题分析[J]. 科技情报开发与经济,2007,17(34).
[3] 王国平,孙传敏.浅论煤矸石资源化及其分类[J].煤炭经济研究,2004(5).
[4] 丰曙霞,王培铭,刘贤萍.煤矸石对水泥熟料水化促进作用及机理研究[C]. 中国硅酸盐学会水泥分会首届学术年会论文集,2009.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州