苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
不同粗骨料级配对橡胶混凝土材料性能的影响
Influence of Different Gradation for Coarse Aggregate on Material Properties of Rubber Concrete
2014年第5期
橡胶混凝土;粗骨料;不同级配;材料性能;机理分析
Rubber concrete; Coarse aggregate; Different gradation; Material properties; Analysis on mechanism
2014年第5期
1000-4637(2014)05-12-04
王 勇,孙洪泉,杜文英,李文兵
苏州科技学院,215011

王 勇,孙洪泉,杜文英,李文兵

浏览量:
1000
摘 要:通过新拌混凝土坍落度、立方体抗压强度和弹性模量的试验,研究了不同粗骨料级配对橡胶混凝土材料性能的影响,并分析了造成这些影响的原因。研究表明,橡胶粉的加入改变了混凝土的受力机理,对于普通混凝土,骨料和水泥石的界面粘结强度决定了混凝土的强度,而影响橡胶混凝土强度的主要因素在于橡胶粉与水泥石的薄弱界面;不同粗骨料级配下,橡胶混凝土抗压强度和弹性模量的影响因素不同于普通混凝土。 Abstract: Material properties of crumb rubber concrete(CRC) with different aggregate gradation are studied, and the reasons resulting to these differences are explained through the experiment of the slump of pumped concrete, compressive strength and elastic modulus of concrete cube. The results show that the crumb rubber in concrete can change stress mechanism of crumb rubber concrete. That is to say the interfacial bond strength from coarse aggregate and cement stone determines the strength of concrete for normal concrete, while the interfacial bond strength from crumb rubber and cement stone determines the strength of CRC. The factors affecting compressive strength and elastic modulus of rubber concrete are different from these factors of ordinary concrete, under the action of different coarse aggregate gradation.
英文名 : Influence of Different Gradation for Coarse Aggregate on Material Properties of Rubber Concrete
刊期 : 2014年第5期
关键词 : 橡胶混凝土;粗骨料;不同级配;材料性能;机理分析
Key words : Rubber concrete; Coarse aggregate; Different gradation; Material properties; Analysis on mechanism
刊期 : 2014年第5期
DOI :
文章编号 : 1000-4637(2014)05-12-04
基金项目 :
作者 : 王 勇,孙洪泉,杜文英,李文兵
单位 : 苏州科技学院,215011

王 勇,孙洪泉,杜文英,李文兵

摘要
参数
结论
参考文献
引用本文

摘   要:通过新拌混凝土坍落度、立方体抗压强度和弹性模量的试验,研究了不同粗骨料级配对橡胶混凝土材料性能的影响,并分析了造成这些影响的原因。研究表明,橡胶粉的加入改变了混凝土的受力机理,对于普通混凝土,骨料和水泥石的界面粘结强度决定了混凝土的强度,而影响橡胶混凝土强度的主要因素在于橡胶粉与水泥石的薄弱界面;不同粗骨料级配下,橡胶混凝土抗压强度和弹性模量的影响因素不同于普通混凝土。

Abstract: Material properties of crumb rubber concrete(CRC) with different aggregate gradation are studied, and the reasons resulting to these differences are explained through the experiment of the slump of pumped concrete, compressive strength and elastic modulus of concrete cube. The results show that the crumb rubber in concrete can change stress mechanism of crumb rubber concrete. That is to say the interfacial bond strength from coarse aggregate and cement stone determines the strength of concrete for normal concrete, while the interfacial bond strength from crumb rubber and cement stone determines the strength of CRC. The factors affecting compressive strength and elastic modulus of rubber concrete are different from these factors of ordinary concrete, under the action of different coarse aggregate gradation.

关键词:
橡胶混凝土;粗骨料;不同级配;材料性能;机理分析
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)三种级配CRC的坍落度相对于其对应的NC均减小,其中小粒径级配和混合粒径级配的下降幅度较大,而大粒径级配的下降幅度很小;三种粒径级配CRC的坍落度相当。
(2)NC掺入橡胶粉后,小粒径级配的混凝土的最终强度下降最小,混合粒径次之,大粒径最大;粗骨料粒径级配对CRC的强度影响不如NC明显,橡胶粉的加入改变了混凝土的受力机理。对于NC,骨料和水泥石的界面粘结强度决定了混凝土的整体强度,而影响CRC强度的主要因素在于橡胶粉与水泥石的薄弱界面,骨料与水泥石的薄弱界面占次要因素。
(3)对于NC,弹性模量由大到小依次是NC-混>NC-大>NC-小;同级配下,CRC的弹性模量均较NC有大幅降低,橡胶粉的加入改善了NC的变形能力,使NC的脆性缺点大大降低。
(4)影响CRC弹性模量的因素与影响其强度的因素不完全一致,不同级配CRC的弹性模量有较大差异,“CRC-大”的弹性模量最大,“CRC-混”次之,“CRC-小”最小。橡胶粉的加入改变了混凝土的变形机理;同级配下CRC较NC弹性下降的幅度,小粒径最大,混合粒径次之,大粒径最小。综合分析,对于CRC而言,小粒径级配粗骨料是最优级配。
[1] 王婧一. 弹性橡胶混凝土抗裂性及疲劳特性研究[D]. 南京:东南大学,2008.
[2] 范国兵.橡胶混凝土的材料特性及其应用技术研究[D]. 郑州:郑州大学,2007.
[3] 丁俊.粗骨料粒径变化对钢筋混凝土构件裂缝演化规律的分形研究[D]. 苏州: 苏州科技学院,2011.
[4] 成振林,王小东.粗骨料对混凝土性能的影响[J].混凝土与水泥制品,2006(6):22-24.
[5] 于本田,王起才,张粉芹,等.粗骨料对混凝土性能影响的试验研究[J].硅酸盐通报,2011,30(6): 71-75.
[6] 林辰,金贤玉,李宗津. 粗骨料粒径和硅灰对混凝土断裂性能影响的试验研究[J]. 混凝土, 2004(10): 32-34.
[7] 张立新,陈兵,吕伟民.集料对混凝土断裂性能影响的研究[J]. 四川建筑科学,2000,26(3):55-57.
[8] 杨卫坤,袁群,冯凌云,等. 橡胶混凝土拌合物性能试验研究[J].人民黄河,2011,33(9):122-124.
[9] G .Giaccio and R . Zerbino .Failure mechanism of concrete-combined effects of coarse aggregates and strength level[J]. Advanced cement based materials,1998(7):41-48.
[10] F.P.Zhou,F.D.Lydon and B.I.G.Barr. Effect of coarse aggregate on elastic modulus and compressive strength of high performance concrete[J]. Cement and concrete research,1995,25(1):177-186.
[11] 周文慧. 弹性混凝土梁受弯性能及分形研究[D]. 苏州:苏州科技学院,2012.
[12] 陈智泽. 橡胶改性高强混凝土基本性能试验研究[D]. 广东:广东工业大学,2007.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州