苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
活性粉末混凝土制备试验研究
Research on Preparation of Reactive Powder Concrete (RPC)
2013年第9期
活性粉末混凝土;流动度;强度;养护方式
Reactive powder concrete; Fluidity; Strength; Curing modes
2013年第9期
1000-4637(2013)09-22-04
973项目(2009CB623203)
马 万,赵铁军,王鹏刚,吴瑞雪
青岛理工大学土木工程学院,266033

马 万,赵铁军,王鹏刚,吴瑞雪

浏览量:
1000
摘 要:研究了活性粉末混凝土(RPC)各组分掺量对其流动度和抗压强度的影响,并对90℃热水养护和90℃蒸汽养护两种养护方式进行了研究。结果表明,水胶比为0.21、硅灰掺量为0.35、石英粉掺量为0.27、石英砂掺量为0.78、粉煤灰取代量为0.3时,可以得到流动度与强度均较好的活性粉末混凝土;90℃蒸汽养护下试件强度较90℃热水养护稍有提高,在3d龄期时强度提高了2.2%。 Abstract: The influences of each component dosage on the fluidity and compressive strength of reactive powder concrete (RPC) are researched. And the effect of curing modes on strength of RPC is also investigated. Results indicate that when water-binder ratio is 0.21 and cement: silica fume: fly ash: quartz sand: quartz powder=0.7: 0.35: 0.3: 0.78: 0.27, the fluidity and strength of RPC will be better. And the compressive strength of the specimens subjected to a 90℃ steam curing is a little higher than those cured in hot water at 90℃. Compared to the specimens cured in hot water at 90℃, the compressive strength of specimens subjected to a 90℃ steam curing increases 2.2% after 3 days curing.
英文名 : Research on Preparation of Reactive Powder Concrete (RPC)
刊期 : 2013年第9期
关键词 : 活性粉末混凝土;流动度;强度;养护方式
Key words : Reactive powder concrete; Fluidity; Strength; Curing modes
刊期 : 2013年第9期
DOI :
文章编号 : 1000-4637(2013)09-22-04
基金项目 : 973项目(2009CB623203)
作者 : 马 万,赵铁军,王鹏刚,吴瑞雪
单位 : 青岛理工大学土木工程学院,266033

马 万,赵铁军,王鹏刚,吴瑞雪

摘要
参数
结论
参考文献
引用本文

摘   要:研究了活性粉末混凝土(RPC)各组分掺量对其流动度和抗压强度的影响,并对90℃热水养护和90℃蒸汽养护两种养护方式进行了研究。结果表明,水胶比为0.21、硅灰掺量为0.35、石英粉掺量为0.27、石英砂掺量为0.78、粉煤灰取代量为0.3时,可以得到流动度与强度均较好的活性粉末混凝土;90℃蒸汽养护下试件强度较90℃热水养护稍有提高,在3d龄期时强度提高了2.2%。

Abstract: The influences of each component dosage on the fluidity and compressive strength of reactive powder concrete (RPC) are researched. And the effect of curing modes on strength of RPC is also investigated. Results indicate that when water-binder ratio is 0.21 and cement: silica fume: fly ash: quartz sand: quartz powder=0.7: 0.35: 0.3: 0.78: 0.27, the fluidity and strength of RPC will be better. And the compressive strength of the specimens subjected to a 90℃ steam curing is a little higher than those cured in hot water at 90℃. Compared to the specimens cured in hot water at 90℃, the compressive strength of specimens subjected to a 90℃ steam curing increases 2.2% after 3 days curing.

关键词:
活性粉末混凝土;流动度;强度;养护方式
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)水胶比增大,RPC的流动度线性增大,强度则先增大后减小。水胶比0.21时,与水胶比0.20时的相比,强度相差不大,但工作性大大提高,更有利于实际应用。
(2)硅灰掺量增加,石英粉掺量减少时,RPC的流动度与强度显著提高;与石英粉相比,硅灰在90℃热水养护条件下更利于提高RPC的强度。
(3)粉煤灰取代水泥可以明显改善RPC的流动度。取代量为0.3时,与取代量为0时相比,强度仅增大1.2%,但流动度增大了41mm,极大地改善了RPC的工作性。
(4)RPC的流动度随着钢纤维掺量的增加急剧减小,而强度随钢纤维掺量增加迅速提高,钢纤维掺量达到150kg/m3时,RPC强度增幅高达37.7%,继续增加钢纤维对强度提高效果不大。
(5)90℃蒸汽养护下RPC强度在各龄期时都要比90℃热水养护的要高,龄期3d时提高幅度达2.2%;90℃蒸汽养护时,RPC后期强度倒缩要比90℃热水养护的低3%。
[1] P. Richard, M. Cheyrezy. Composition of Reactive Powder Concrete[J]. Cement and Concrete Research, 1995, 25(7): 1501-1511.
[2] P. Y. Blais, M. Couture. Precast, Pre-stressed Pedestrian Bridge-World’s First Reactive Powder Concrete Structure[J]. PCI Journal, 1999, 9(10): 60-71.
[3] 何峰, 黄政宇. 200~300MPa活性粉末混凝土(RPC)的配制技术研究[J]. 混凝土与水泥制品, 2000(4):3-7.
[4] 闫光杰, 阎贵平, 安明喆, 等. 200MPa级活性粉末混凝土试验研究[J]. 铁道学报, 2004, 26(2): 116-119.
[5] 江桂华, 林东, 林永权, 等. 养护制度对活性粉末混凝土强度的影响及其机理研究[J]. 广东建材, 2010(1): 18-21.
[6] 时术兆, 齐砚勇, 严云, 等. 多元凝胶紧密堆积对活性粉末混凝土的影响[J]. 水泥工程, 2009(1): 77-80.
[7] 何峰, 黄政宇. 养护制度对活性粉末混凝土(RPC)强度的影响研究[J]. 混凝土, 2000(2): 31-34.
[8] 吴中伟, 廉慧珍. 高性能混凝土[M]. 北京: 中国铁道出版社, 1999.
[9] 张胜, 周锡龄, 谢友均, 等. 养护制度对活性粉末混凝土强度及微观结构影响的研究[J]. 混凝土, 2007(6): 16-18.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州