苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
免煅烧石膏-矿渣-棉花秸秆砌块的制备
Preparation for Non-calcined Gypsum-slag-cotton Straw Blocks
2013年第12期
免煅烧脱硫石膏;矿渣;棉花秸秆;砌块
Non-calcined Desulphurization Gypsum; Slag; Cotton Straw; Block
2013年第12期
1000-4637(2013)12-47-04
江苏省基础研究重点项目(BK2010036);江苏省新型环保重点实验室面上项目(AE201011)
焦宝龙1,2,焦宝祥1,黄 芳2,李玉寿1,郭 伟1
1. 盐城工学院材料工程学院,224051;2.贵州大学材料科学与冶金工程学院,贵阳550025

焦宝龙1,2,焦宝祥1,黄 芳2,李玉寿1,郭 伟1

浏览量:
1000
摘  要:研究了氢氧化钠和复合激发剂CSN对脱硫石膏-矿渣胶结料强度的影响以及棉花秸秆对材料强度、导热系数和表观密度的影响,并制备了石膏砌块。试验结果表明,复合激发剂CSN对胶结料强度的改善效果优于氢氧化钠,28d最高抗折强度和抗压强度分别达到6.2MPa和46.5MPa;在其中添加棉花秸秆后,随着棉花秸秆掺量的增加,试样的强度、导热系数和表观密度都不断减小。当在70%原状脱硫石膏和30%矿渣中,添加4%CSN复合激发剂和10%棉花秸秆时,其抗折和抗压强度分别达2.1MPa和9.1MPa,导热系数达0.134W/m·K;由其制备的砌块抗折载荷为3056N,表观密度为975kg/m3。Abstract:Thegypsumblockwaspreparedbytheoriginaldesulphurizationgypsumasrawmaterials,alittleslag,someactivatorsandcottonstraw.TheinfluenceofNaOHandcompoundstimulatorCSNonthestrengthofdesulphurizationgypsum-slagsystemwasdiscussed.Andtheeffectofthecottonstrawonthestrength,thermalconductivityandapparentdensityofthematerialwasalsostudied.TheresultsshowthattheeffectofCSNonthestrengthofthebinderisbetterthanthatofNaOH.The28dflexuralstrengthandcompressivestrengthofthecementitiousmaterialsare6.2MPaand46.5MParespectively.Furthermore,thestrength,thermalconductivityandapparentdensityofthespecimensdecreasewithincreasingthecontentofcottonstraw.Whenadding4%CSNand10%cottonstrawtothemixtureof70%originaldesulphurizationgypsumand30%slag,theflexuralstrengthandcompressivestrengthofthespecimenare2.1MPaand9.1MParespectively,anditsthermalconductivityis0.134W/m·K.Inaddition,thefractureloadandtheapparentdensityoftheblockpreparedbyusingtheoptimumproportionare3056Nand975kg/m3respectively.
英文名 : Preparation for Non-calcined Gypsum-slag-cotton Straw Blocks
刊期 : 2013年第12期
关键词 : 免煅烧脱硫石膏;矿渣;棉花秸秆;砌块
Key words : Non-calcined Desulphurization Gypsum; Slag; Cotton Straw; Block
刊期 : 2013年第12期
DOI :
文章编号 : 1000-4637(2013)12-47-04
基金项目 : 江苏省基础研究重点项目(BK2010036);江苏省新型环保重点实验室面上项目(AE201011)
作者 : 焦宝龙1,2,焦宝祥1,黄 芳2,李玉寿1,郭 伟1
单位 : 1. 盐城工学院材料工程学院,224051;2.贵州大学材料科学与冶金工程学院,贵阳550025

焦宝龙1,2,焦宝祥1,黄 芳2,李玉寿1,郭 伟1

摘要
参数
结论
参考文献
引用本文

摘   要:研究了氢氧化钠和复合激发剂CSN对脱硫石膏-矿渣胶结料强度的影响以及棉花秸秆对材料强度、导热系数和表观密度的影响,并制备了石膏砌块。试验结果表明,复合激发剂CSN对胶结料强度的改善效果优于氢氧化钠,28d最高抗折强度和抗压强度分别达到6.2MPa和46.5MPa;在其中添加棉花秸秆后,随着棉花秸秆掺量的增加,试样的强度、导热系数和表观密度都不断减小。当在70%原状脱硫石膏和30%矿渣中,添加4%CSN复合激发剂和10%棉花秸秆时,其抗折和抗压强度分别达2.1MPa和9.1MPa,导热系数达0.134 W/m·K;由其制备的砌块抗折载荷为3056N,表观密度为975kg/m3

Abstract: The gypsum block was prepared by the original desulphurization gypsum as raw materials, a little slag, some activators and cotton straw. The influence of NaOH and compound stimulator CSN on the strength of desulphurization gypsum-slag system was discussed. And the effect of the cotton straw on the strength, thermal conductivity and apparent density of the material was also studied. The results show that the effect of CSN on the strength of the binder is better than that of NaOH. The 28d flexural strength and compressive strength of the cementitious materials are 6.2MPa and 46.5MPa respectively. Furthermore, the strength, thermal conductivity and apparent density of the specimens decrease with increasing the content of cotton straw. When adding 4% CSN and 10% cotton straw to the mixture of 70% original desulphurization gypsum and 30% slag, the flexural strength and compressive strength of the specimen are 2.1MPa and 9.1MPa respectively, and its thermal conductivity is 0.134 W/m·K. In addition, the fracture load and the apparent density of the block prepared by using the optimum proportion are 3056N and 975 kg/m3 respectively.

关键词:
免煅烧脱硫石膏;矿渣;棉花秸秆;砌块
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)复合激发剂CSN对脱硫石膏-矿渣胶结料强度的改善效果优于氢氧化钠。当激发剂CSN的掺量为4%时,脱硫石膏-矿渣胶凝材料28d的抗折强度和抗压强度分别达到6.2MPa和46.5MPa。 
(2)随着秸秆掺量的增加,脱硫石膏-矿渣胶结料的强度、表观密度和导热系数都不断降低。当秸秆掺量为10%时,试样的导热系数满足保温材料中导热系数小于0.14W/m·K的要求。由其制备的砌块抗折载荷达3056N,表观密度为975kg/m3
[1] 中华人民共和国环境保护部.中国环境状况公报.2011.
[2] 王晓平.脱硫石膏在混凝土中应用的可行性分析[J].上海建材,2011(1):11-14.
[3] 于洋,柏玉婷,李国忠.掺加外加剂对脱硫石膏砌块强度的影响探讨[J].建筑砌块与砌块建筑,2008(5):50-51.
[4] 刘民荣,李国忠,柏玉婷.聚合物改性脱硫建筑石膏的研究[J].武汉理工大学学报,2009,31(16):23-26.
[5] 周可友.改性石膏耐水性研究及新型石膏空心砖制备[D].南京:东南大学硕士学位论文.
[6] 郝润霞.脱硫石膏/钢渣复合胶凝材料力学性能的研究[J].内蒙古科技与经济,2012(2):78-82.
[7] 范立瑛.脱硫石膏基钢渣胶凝材料的研制[D].济南:济南大学硕士学位论文.
[8] S. Marinkovic, A. Kostic-Pulek. Examination of the system fly ash-lime-calcined gypsum-water[J]. Journal of Physics and Chemistry of Solids,2007,68(5):1121-1125.
[9] Leiva C,García Arenas C,Vilches L F,et al.Use of FGD gypsum in fire resistant panels[J]. Waste Management,2010,30(6):1123-1129.
[10] 黄孙恺,俞新浩.用烟气脱硫石膏制备建筑石膏的工艺技术[J]. 新型建筑材料,2005(1):27-28.
[11] 叶蓓红,谈晓青. 我国脱硫石膏与脱硫建筑石膏质量问题及成因分析[J]. 粉煤灰,2009(6):38-40.
[12] 卫生,彭荣,张增寿.新型化学石膏砌块[J].建筑砌块与砌块建筑,1999(3):5-9.
[13] Antonio Telesca, Milena Marroccoli, Daniela Calabrese,Gian Lorenzo Valenti,Fabio Montagnaro. Flue gas desulfurization gypsum and coal fly ash as basic components of prefabricated building materials[J].Waste Management,2013,33:628-633.
[14] AriozO, Tokyay M, Arioz E,et al. Properties of fly ash-FGD gypsum-lime based products[J].Journal of the Australasian Ceramic Society,2006,42(1):13-21. 
[15] Honggen Qin, Xiaoqin Liu, Gang Li. Preparation and properties of desulfurization gypsum-slag hydraulic cementitious materials[J].Procedia Engineering,2012,27:244-252.
[16] 王雪娇,王新堂,张振文.矿物掺合料对脱硫二水石膏粉煤灰复合胶凝材料强度的影响[J].宁波大学学报,2011,24(3):90-94.
[17] 位建强,刘巧玲,曹明莉.脱硫石膏-粉煤灰-矿粉复合胶结材改性研究[J].新型建筑材料,2010(4):9-12.
[18] 陈琳,李灿华,刘思.非煅烧脱硫石膏钢渣砖的研制[J].中国废钢铁,2011(1):44-48.
[19] 王永泽,杨立,邵明胜,等.棉花秸秆厌氧发酵产沼气工艺条件的研究[J].现代农业科技,2009(1):251-252.
[20] Deng Hui,Zhang Genlin,Xu Xiaolin,et al. Optimization of preparation of activated carbon from cotton stalk by microwave assisted phosphoric acid-chemical activation [J]. Journal of Hazardous Materials,2010,182:217-224.
[21] Rebecca A Silverstein,Ye Chen,et al.A comparison of chemical pretreatment methods for improving saccharification of cotton stalks[J].Bioresource Technology,2007,98:3000-3011.
 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州