苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
隧洞初期支护喷射混凝土结构纤维与钢筋网增强方式对比研究
Corresponding Research on Structural Fibers of Shotcrete in Primary Supporting for Mountain Tunnel and Steel Fabric Reinforcemen
2014年第2期
结构纤维RL60;钢筋网;喷射混凝土;等效抗弯强度;弯曲韧性
Structural fiber RL60; Steel fabric; Shotcrete; Equivalent flexural strength; Flexural toughness
2014年第2期
1000-4637(2014)02-47-04
赵 正1, 李 强2, 刘国平1, 施慧聪1,姚 欣1
1.上海罗洋新材料科技有限公司,200092;2.中交一航局第一工程有限公司,天津 300456

赵 正1, 李 强2, 刘国平1, 施慧聪1,姚 欣1

浏览量:
1000
摘 要:对采用钻爆法施工的隧洞初期支护喷射混凝土的两种增强方式(结构纤维RL60、钢筋网)进行了研究。结果表明,通过等效抗弯能力测试与计算可以得出RL60纤维与配筋率之间的对应关系;RL60纤维在一定掺量下可以超过钢筋网的弯曲韧性能量吸收值,而且其极限抗弯承载力和低挠度残余抗弯承载力均高于钢筋网。 Abstract: When using the drilling and blasting method, the two kinds of reinforcement (structural fibers RL60 and steel fabrics) for shotcrete are studied in tunnel initial support. The results indicate that the corresponding relationship between the content of RL60 fiber and the ratio of reinforcement is set through equivalent flexural capacity tests, and the flexural toughness energy absorption value of RL60 with certain content can surpass that of the steel fabric, and its ultimate flexural capacity and residual flexural capacity in low deflection range are higher than those of the steel fabric.
英文名 : Corresponding Research on Structural Fibers of Shotcrete in Primary Supporting for Mountain Tunnel and Steel Fabric Reinforcemen
刊期 : 2014年第2期
关键词 : 结构纤维RL60;钢筋网;喷射混凝土;等效抗弯强度;弯曲韧性
Key words : Structural fiber RL60; Steel fabric; Shotcrete; Equivalent flexural strength; Flexural toughness
刊期 : 2014年第2期
DOI :
文章编号 : 1000-4637(2014)02-47-04
基金项目 :
作者 : 赵 正1, 李 强2, 刘国平1, 施慧聪1,姚 欣1
单位 : 1.上海罗洋新材料科技有限公司,200092;2.中交一航局第一工程有限公司,天津 300456

赵 正1, 李 强2, 刘国平1, 施慧聪1,姚 欣1

摘要
参数
结论
参考文献
引用本文

摘   要:对采用钻爆法施工的隧洞初期支护喷射混凝土的两种增强方式(结构纤维RL60、钢筋网)进行了研究。结果表明,通过等效抗弯能力测试与计算可以得出RL60纤维与配筋率之间的对应关系;RL60纤维在一定掺量下可以超过钢筋网的弯曲韧性能量吸收值,而且其极限抗弯承载力和低挠度残余抗弯承载力均高于钢筋网。

Abstract: When using the drilling and blasting method, the two kinds of reinforcement (structural fibers RL60 and steel fabrics) for shotcrete are studied in tunnel initial support. The results indicate that the corresponding relationship between the content of RL60 fiber and the ratio of reinforcement is set through equivalent flexural capacity tests, and the flexural toughness energy absorption value of RL60 with certain content can surpass that of the steel fabric, and its ultimate flexural capacity and residual flexural capacity in low deflection range are higher than those of the steel fabric.

关键词:
结构纤维RL60;钢筋网;喷射混凝土;等效抗弯强度;弯曲韧性
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)通过等效抗弯能力计算,可以得出在同一弯矩作用下分别所需的配筋率和纤维混凝土等效抗弯强度。
(2)经试验得出RL60纤维掺量(Vf)与等效抗弯强度(fe)之间的函数关系式,并通过等效抗弯能力计算得出RL60纤维各种掺量所对应的配筋率。
(3)弯曲韧性能量吸收试验表明,掺入3kg/m3和6kg/m3纤维后,峰值荷载分别比基准提高了22.9%和14.0%,而钢筋网没有提高;RL60在3kg/m3掺量下韧性值低于?覫6@200钢筋网,但掺入6kg/m3纤维在0~35mm挠度范围内能量吸收值均高于6@200钢筋网,而且在18mm低挠度范围内,残余承载力均高于钢筋网。
(4)抗弯承载力和大挠度韧性测试表明,RL60纤维在一定掺量下可以替代钢筋网,而且其极限抗弯承载力和低挠度残余抗弯承载力均高于钢筋网。
[1] Einar Broch, etc. The inner lining system in Norwegian traffic tunnels[J]. Tunnelling and Underground Space Technology, 2002,17(3): 305-314.
[2] O. Cengiz, L. Turanli. Comparative evaluation of steel mesh, steel fibre and high-performance polypropylene fibre reinforced shotcrete in panel test[J]. Cement and Concrete Research, 2004, 34(8):1357-1364.
[3] Anders Ansell. Investigation of shrinkage cracking in shot-crete on tunnel drains[J]. Tunnelling and Underground Space Technology,2010,25(5): 607-613.
[4] R. Lackner, H.A. Mang. Cracking in shotcrete tunnel shells [J]. Engineering Fracture Mechanics,2003,70(7-8):1047-1068.
[5] Ann Lamontagne, Michel Pigeon. The influence of polyprop-ylene fibers and aggregate grading on the properties of dry-mix shotcrete[J]. Cement and Concrete Research, 1995, 25(2):293-298.
[6] Vojkan Jovi?觬ic, etc. The application of fiber reinforced shotcrete as primary support for a tunnel in flysch[J]. Tunnelling and Underground Space Technology, 2009, 24(6): 723-730.
[7] 中华人民共和国国家质量监督检验检疫总局,中华人民共和国建设部. GB 50086—2001 锚杆喷射混凝土支护技术规范[S].北京:中国计划出版社,2001.
[8] ASTM C1609/C1609M-10, standard test method for flexural performance of fiber-reinforced concrete (using beam with third-point loading)[S].
[9] ASTM C1550-10, standard test method for flexural toughness of fiber reinforced concrete (using centrally loaded round panel)[S].

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州