苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
矿物掺合料对混凝土内部碱度影响研究
Effect of Mineral Admixture on the Internal Alkalinity of Concrete
2019年第11期
粉煤灰;矿粉;磨细石英砂;混凝土碱度
Fly ash; Slag; Ground quartz sand; Concrete alkalinity
2019年第11期
10.19761/j.1000-4637.2019.11.025.05
2018年度苏州市建设科研项目(苏住建科[2018]6号);江苏省建设厅科技计划项目(苏建计[2016]527号);2016年度苏州科技大学科研计划项目。
姜正平1,宋旭艳1,明 维2
1.苏州科技大学土木工程学院,215011;2.宁波中淳高科股份有限公司,315145

姜正平1,宋旭艳1,明 维2

董超,冯晨,杨进波,等.机制砂质量指标及对混凝土性能的影响分析[J].混凝土与水泥制品,2019(11):21-24.

DONG C,FENG C,YANG J B,et al.Analysis of the Quality Index of Manufactured Sand and Its Influence on Concrete Performance[J].China Concrete and Cement Products,2019(11):21-24.

浏览量:
1000
摘 要:通过掺加粉煤灰、矿粉、磨细石英砂等矿物掺合料制备了不同强度等级的混凝土,研究了矿物掺合料掺量、种类以及水灰比、混凝土内部不同深度对混凝土内部碱度的影响,并对比分析了不同矿物掺合料混凝土的抗硫酸盐侵蚀性能。研究结果表明,适量的矿物掺合料不仅可节约水泥,优化混凝土结构,提高混凝土抗硫酸盐侵蚀能力,同时对混凝土内部碱度影响较小。混凝土内部碱度分布基本均匀,不同深度的孔溶液中pH值基本一致;且混凝土的水灰比对其碱度几乎没有影响。 Abstract: The concrete with different strength grades was prepared by adding mineral admixtures such as fly ash, slag and ground quartz sand. The effects of mineral admixture content and type, W/C and different depth of concrete on the internal alkalinity of concrete were studied. The sulfate corrosion resistance of concrete with different mineral admixtures was compared. The results show that appropriate mineral admixtures can not only save cement, optimize concrete structure and improve the sulfate resistance of concrete, but also have little influence on the internal alkalinity of concrete. The alkalinity distribution in concrete is basically uniform, and the pH value in pore solution of different depths is basically the same, and the water cement ratio in concrete has little effect on its alkalinity.
英文名 : Effect of Mineral Admixture on the Internal Alkalinity of Concrete
刊期 : 2019年第11期
关键词 : 粉煤灰;矿粉;磨细石英砂;混凝土碱度
Key words : Fly ash; Slag; Ground quartz sand; Concrete alkalinity
刊期 : 2019年第11期
DOI : 10.19761/j.1000-4637.2019.11.025.05
文章编号 :
基金项目 : 2018年度苏州市建设科研项目(苏住建科[2018]6号);江苏省建设厅科技计划项目(苏建计[2016]527号);2016年度苏州科技大学科研计划项目。
作者 : 姜正平1,宋旭艳1,明 维2
单位 : 1.苏州科技大学土木工程学院,215011;2.宁波中淳高科股份有限公司,315145

姜正平1,宋旭艳1,明 维2

董超,冯晨,杨进波,等.机制砂质量指标及对混凝土性能的影响分析[J].混凝土与水泥制品,2019(11):21-24.

DONG C,FENG C,YANG J B,et al.Analysis of the Quality Index of Manufactured Sand and Its Influence on Concrete Performance[J].China Concrete and Cement Products,2019(11):21-24.

摘要
参数
结论
参考文献
引用本文

摘  要:通过掺加粉煤灰、矿粉、磨细石英砂等矿物掺合料制备了不同强度等级的混凝土,研究了矿物掺合料掺量、种类以及水灰比、混凝土内部不同深度对混凝土内部碱度的影响,并对比分析了不同矿物掺合料混凝土的抗硫酸盐侵蚀性能。研究结果表明,适量的矿物掺合料不仅可节约水泥,优化混凝土结构,提高混凝土抗硫酸盐侵蚀能力,同时对混凝土内部碱度影响较小。混凝土内部碱度分布基本均匀,不同深度的孔溶液中pH值基本一致;且混凝土的水灰比对其碱度几乎没有影响。
Abstract: The concrete with different strength grades was prepared by adding mineral admixtures such as fly ash, slag and ground quartz sand. The effects of mineral admixture content and type, W/C and different depth of concrete on the internal alkalinity of concrete were studied. The sulfate corrosion resistance of concrete with different mineral admixtures was compared. The results show that appropriate mineral admixtures can not only save cement, optimize concrete structure and improve the sulfate resistance of concrete, but also have little influence on the internal alkalinity of concrete. The alkalinity distribution in concrete is basically uniform, and the pH value in pore solution of different depths is basically the same, and the water cement ratio in concrete has little effect on its alkalinity.

关键词:
粉煤灰;矿粉;磨细石英砂;混凝土碱度
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)尽管矿物掺合料的掺加会影响混凝土中碱储备量,但在适量的掺量范围内,利用矿物掺合料代替水泥,不仅可节约水泥,优化混凝土结构,同时对混凝土内部碱度影响较小,可以满足工程需求。其中,自然养护的中低强度等级混凝土中粉煤灰和矿粉的掺量,宜分别在35%和30%以内,而采用高压养护的高强度等级混凝土中磨细砂掺量宜在20%以内。
(2)各强度等级的混凝土内部碱度分布基本均匀,不同深度的孔溶液中pH值基本一致;同时混凝土中水灰比对其碱度几乎没有影响。
(3)随着矿物掺合料掺量的增加,混凝土抗硫酸盐侵蚀能力明显提高。适量的掺量范围内,采用高压养护的磨细石英砂混凝土抗硫酸盐侵蚀性能优于粉煤灰和矿粉。

 

[1] 姚贤华,冯忠居,管俊峰,等.不同掺合料对盐碱腐蚀条件下干湿循环后混凝土性能的影响[J].工业建筑,2018,48(3):6-10.
[2] 吴中伟,廉慧珍.高性能混凝土[M].北京:中国铁道出版社,1999.
[3] 冯乃谦.高性能混凝土[M].北京:中国建筑工业出版社,1996.
[4] 刘志勇.基于环境的海工混凝土耐久性试验与寿命预制方法研究[D].南京:东南大学,2006.
[5] 洪乃丰.混凝土碱度与钢筋锈蚀[J].混凝土与水泥制品,1990(4):16-18.
[6] CONSTANTINER D,DIAMOND S.Pore Solution Analysis: Are There Pressure Effects in"Mechanisms of Chemical Degrada tion of Cement-based Systems"[M].London,1997.
[7] MACPHEE D E,GLASSER F P.A modelling approach to prediction of pore fluid alkalinity in concretes. Proceedings of the 10th International Conference on Alkali-Aggregate Reaction[J].Melbourne,1996:792-797.
[8] 孟志良,任继生,刘志刚,等.高掺量粉煤灰混凝土的孔隙液相碱度与护筋性[J].河北农业大学学报,2000,23(3):95-97.
[9] 吕林女,何永佳,王晓,等.掺合料复掺对水泥基材料孔溶液碱度的影响[J].河南建材,2004(3):3-5.
[10] 沈旦申.粉煤灰混凝土[M].北京:中国铁道出版社,1989.
[11] 王边,高建明,朱亚菲,等.矿渣微粉对混凝土强度和耐久性影响的试验研究[J].混凝土与水泥制品,2001(5):7-9.

董超,冯晨,杨进波,.机制砂质量指标及对混凝土性能的影响分析[J].混凝土与水泥制品,2019(11):21-24.

DONG C,FENG C,YANG J B,et al.Analysis of the Quality Index of Manufactured Sand and Its Influence on Concrete Performance[J].China Concrete and Cement Products,2019(11):21-24.

 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州