苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
钢纤维与PVA纤维对超高性能混凝土强度及抗冲磨性能影响研究
Effect of Steel Fiber and PVA Fiber on Strength and Abrasion Resistance Performance of Ultra High Performance Concrete
2019年第11期
钢纤维;PVA纤维;超高性能混凝土;抗冲磨
Steel fiber; PVA fiber; Ultra-high performance concrete; Impact wear resistance
2019年第11期
10.19761/j.1000-4637.2019.11.039.04
基金项目:国家自然科学基金项目(51579195)。
苏 骏1,2,李 磊1,吴 鹏2,蔡新华3
1.湖北工业大学土木建筑与环境学院,武汉 430068;2.湖北省桥梁安全监控技术与装备工程技术研究中心,武汉 430068;3.武汉大学水资源与水电工程科学国家重点实验室,430072

苏 骏1,2,李 磊1,吴 鹏2,蔡新华3

苏骏,李磊,吴鹏,等.钢纤维与PVA纤维对超高性能混凝土强度及抗冲磨性能影响研究[J].混凝土与水泥制品,2019(11):39-42.

SU J,LI L,WU P,et al.Effect of Steel Fiber and PVA Fiber on Strength and Abrasion Resistance Performance of Ultra High Performance Concrete[J].China Concrete and Cement Products,2019(11):39-42.

浏览量:
1000
摘 要:为了研究不同纤维对超高性能混凝土(UHPC)力学性能和抗冲磨性能的影响,分别在UHPC中掺入不同体积分数的钢纤维和 PVA纤维,进行了抗压、抗拉及抗冲磨试验。结果表明,钢纤维对UHPC抗压性能的提升效果优于PVA纤维;钢纤维与PVA纤维均能显著提升UHPC的抗拉性能;PVA纤维对UHPC抗冲磨性能的提升效果优于钢纤维。 Abstract: In order to study the influence of different fibers on the mechanical properties and impact wear resistance of Ultra-high performance concrete (UHPC), different volume fractions of steel fiber and PVA fiber were mixed in UHPC to carry out compression, tensile and impact wear resistance tests. The results show that the effect of steel fiber on UHPC compression performance is better than PVA fiber. Steel fiber and PVA fiber can significantly improve the tensile properties of UHPC. The effect of PVA fiber on UHPC impact wear resistance is better than steel fiber.
英文名 : Effect of Steel Fiber and PVA Fiber on Strength and Abrasion Resistance Performance of Ultra High Performance Concrete
刊期 : 2019年第11期
关键词 : 钢纤维;PVA纤维;超高性能混凝土;抗冲磨
Key words : Steel fiber; PVA fiber; Ultra-high performance concrete; Impact wear resistance
刊期 : 2019年第11期
DOI : 10.19761/j.1000-4637.2019.11.039.04
文章编号 :
基金项目 : 基金项目:国家自然科学基金项目(51579195)。
作者 : 苏 骏1,2,李 磊1,吴 鹏2,蔡新华3
单位 : 1.湖北工业大学土木建筑与环境学院,武汉 430068;2.湖北省桥梁安全监控技术与装备工程技术研究中心,武汉 430068;3.武汉大学水资源与水电工程科学国家重点实验室,430072

苏 骏1,2,李 磊1,吴 鹏2,蔡新华3

苏骏,李磊,吴鹏,等.钢纤维与PVA纤维对超高性能混凝土强度及抗冲磨性能影响研究[J].混凝土与水泥制品,2019(11):39-42.

SU J,LI L,WU P,et al.Effect of Steel Fiber and PVA Fiber on Strength and Abrasion Resistance Performance of Ultra High Performance Concrete[J].China Concrete and Cement Products,2019(11):39-42.

摘要
参数
结论
参考文献
引用本文

摘  要:为了研究不同纤维对超高性能混凝土(UHPC)力学性能和抗冲磨性能的影响,分别在UHPC中掺入不同体积分数的钢纤维和 PVA纤维,进行了抗压、抗拉及抗冲磨试验。结果表明,钢纤维对UHPC抗压性能的提升效果优于PVA纤维;钢纤维与PVA纤维均能显著提升UHPC的抗拉性能;PVA纤维对UHPC抗冲磨性能的提升效果优于钢纤维。
Abstract: In order to study the influence of different fibers on the mechanical properties and impact wear resistance of Ultra-high performance concrete (UHPC), different volume fractions of steel fiber and PVA fiber were mixed in UHPC to carry out compression, tensile and impact wear resistance tests. The results show that the effect of steel fiber on UHPC compression performance is better than PVA fiber. Steel fiber and PVA fiber can significantly improve the tensile properties of UHPC. The effect of PVA fiber on UHPC impact wear resistance is better than steel fiber.

关键词:
钢纤维;PVA纤维;超高性能混凝土;抗冲磨
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)掺入钢纤维的UHPC抗压性能得到显著的增强,随着钢纤维体积分数的增大,UHPC抗压性能提升,钢纤维体积掺量为3%的UHPC抗压强度为未掺纤维UHPC的1.6倍。PVA纤维掺量在0~1.0%时,UHPC的抗压强度与无纤维UHPC相比有所减小,说明PVA纤维无法起到增强UHPC抗压性能的作用。
(2) 掺加钢纤维和PVA纤维的UHPC抗拉性能均有较大提高,钢纤维掺量为0.5%、1.0%、2.0%、3.0%时,抗拉强度分别增长21%、130%、116%和227%,PVA纤维掺量为0.3%、0.5%、0.7%、1.0%时,抗拉强度分别增长45%、116%、24%、120%。PVA纤维和钢纤维均有助于提升UHPC的抗拉强度。在本试验范围内,两种纤维最高掺量时UHPC的抗拉强度都达到最大,最佳钢纤维掺量为3.0%,最佳PVA纤维掺量为1.0%.
(3)钢纤维体积掺量为0.5%和PVA纤维体积掺量为0.3%时,UHPC抗冲磨强度均低于未掺纤维的UHPC;其余纤维掺量下,UHPC抗冲磨强度均高于未掺纤维的UHPC。在本试验范围内,钢纤维的最佳掺量为3%,PVA纤维的最佳掺量为1%,此时,UHPC抗冲磨强度分别提高29.8%和53.6%。整体而言,掺加PVA纤维的UHPC抗冲磨强度较掺加钢纤维的UHPC抗冲磨强度略高。
 

[1] 李金玉.中国大坝混凝土中的碱骨料反应[J].水力发电, 2005,31(1):34-37.
[2] 王洪镇,王洪航.航抗冲磨外加剂在水工混凝土中的应用研究[J].混凝土与水泥制品,2008(4):20-22.
[3] BUCK J J,MCDOWELL D L,ZHOU M.Effect of microstructure on load-carrying and energy-dissipation capacities of UHPC[J].Cement and Concrete Research,2013,43(1):34-50.
[4] HABEL K,GAUVREAU P.Response of ultra-high performance fiber reinforced concrete (UHPFRC) to impact and static loading[J].Cement and Concrete Composites,2008,30(10):938-946.
[5] 陈宝春,季韬,黄卿维,等.超高性能混凝土研究综述[J].建筑科学与工程学报,2014,31(3):1-24.
[6] 杜修力,田予东,窦国钦.纤维超高强混凝土的制备及力学性能试验研究[J].混凝土与水泥制品,2011(2):44-48+71.
[7] 邓中正,杨华全,肖开涛.掺纤维抗冲磨混凝土性能试验研究[J].混凝土,2017(4):8-10+14.

苏骏,李磊,吴鹏,.钢纤维与PVA纤维对超高性能混凝土强度及抗冲磨性能影响研究[J].混凝土与水泥制品,2019(11):39-42.

SU J,LI L,WU P,et al.Effect of Steel Fiber and PVA Fiber on Strength and Abrasion Resistance Performance of Ultra High Performance Concrete[J].China Concrete and Cement Products,2019(11):39-42.

 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州