苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
黄河淤泥制备黏土基墙体材料性能研究
Research on Properties of Clay-based Wall Material Prepared by Yellow River Silt
2012年第5期
黄河淤泥;活性激发;有机固化
Yellow River silt; Active stimulation; Organic solidification
2012年第5期
1000-4637(2012)05-54-04
国家自然科学基金项目(51142006、50972099)
杨久俊,刘俊霞,陈晓飞,张 磊
1. 郑州大学材料科学与工程学院,450000; 2. 天津城市建设学院材料科学与工程系,300384

杨久俊,刘俊霞,陈晓飞,张 磊

浏览量:
1000
摘 要:分析了黄河淤泥的特性,通过离子交换激发黄河淤泥活性,讨论了不同激发剂的活化效果。以活化土为主要原料,掺入无机固化剂、有机固化剂及黄麻纤维制备黏土基墙体材料,并研究了固化强化措施对其性能的影响。结果表明,2%的复合激发剂(水玻璃/氯化钙=1/1)能有效活化黄河淤土,采用活化土:无机固化剂:砂=65:25:10的配合比,辅以1.8%聚丙烯酸钙和0.8%的黄麻纤维即可制备出满足MU10等级要求的黏土基墙体材料。 Abstract: Activity of Yellow River silt is stimulated through the ion exchange on the basis of its characteristics analysis and the activation effects of different agents are discussed. Clay-based wall materials are prepared by activated silt and cementitious binder as main raw materials supplemented by organic solidification agent and jute fiber, and the strengthened measures on its properties effects have been studied. The results show that 2% compound activator (water glass/calcium chloride=1/1) can effectively activate the Yellow River silt. Clay-based wall materials meeting the demand of MU10 brick can be prepared with mixture ratio of activated silt: cementitious binder: sand=65: 25: 10 strengthened by 1.8% polypropylene calcium and 0.8% jute fiber.
英文名 : Research on Properties of Clay-based Wall Material Prepared by Yellow River Silt
刊期 : 2012年第5期
关键词 : 黄河淤泥;活性激发;有机固化
Key words : Yellow River silt; Active stimulation; Organic solidification
刊期 : 2012年第5期
DOI :
文章编号 : 1000-4637(2012)05-54-04
基金项目 : 国家自然科学基金项目(51142006、50972099)
作者 : 杨久俊,刘俊霞,陈晓飞,张 磊
单位 : 1. 郑州大学材料科学与工程学院,450000; 2. 天津城市建设学院材料科学与工程系,300384

杨久俊,刘俊霞,陈晓飞,张 磊

摘要
参数
结论
参考文献
引用本文

摘   要:分析了黄河淤泥的特性,通过离子交换激发黄河淤泥活性,讨论了不同激发剂的活化效果。以活化土为主要原料,掺入无机固化剂、有机固化剂及黄麻纤维制备黏土基墙体材料,并研究了固化强化措施对其性能的影响。结果表明,2%的复合激发剂(水玻璃/氯化钙=1/1)能有效活化黄河淤土,采用活化土:无机固化剂:砂=65:25:10的配合比,辅以1.8%聚丙烯酸钙和0.8%的黄麻纤维即可制备出满足MU10等级要求的黏土基墙体材料。

Abstract: Activity of Yellow River silt is stimulated through the ion exchange on the basis of its characteristics analysis and the activation effects of different agents are discussed. Clay-based wall materials are prepared by activated silt and cementitious binder as main raw materials supplemented by organic solidification agent and jute fiber, and the strengthened measures on its properties effects have been studied. The results show that 2% compound activator (water glass/calcium chloride=1/1) can effectively activate the Yellow River silt. Clay-based wall materials meeting the demand of MU10 brick can be prepared with mixture ratio of activated silt: cementitious binder: sand=65: 25: 10 strengthened by 1.8% polypropylene calcium and 0.8% jute fiber.

关键词:
黄河淤泥;活性激发;有机固化
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)当水玻璃和氯化钙以1:1的比例复配,以2%的掺量加入土样中时,能够明显地提高土样的抗压强度,抗压强度较未激发时的抗压强度提高了6%。
(2)活化黄河淤土掺量由75%降至65%,抗压强度呈明显的上升趋势,但随着激活土掺量的继续降低,试件的抗压强度变化不大。
(3)以65%的活化黄河淤泥和25%无机固化剂为主要材料,并辅以掺加1.8%的聚丙烯酸钙和0.8%的黄麻纤维强化固化,能够配置出抗压强度达到13.5 MPa、软化系数为0.87 的黏土基墙体材料,满足了GB/T5101-2003的MU10等级的黏土砖的性能要求。
[1] 谭文英,汪益敏,陈页开,等.土固化材料的研究现状[J].中外公路,2004(8): 169-172.
[2] Gerald A. Miller, Shahirar Azad. Influence of soil type on stabilization with cement kiln dust[J]. Construction and Building Materials, 200014(2): 89-97.
[3] 苏群,徐渊博,张复实. 国际以及国内土壤固化剂的研究现状和前景展望[J]. 黑龙江工程学院学报:自然科学版,2005(9): 1-3.
[4] 柯结伟,庞有师,陈志勇. 土壤固化技术研究与工程应用现状[J]. 华东公路,2007(5): 48-52.
[5] M KAMON, H GU. Improvement of mechanical properties of ferrum lime stabilized soil with the addition of aluminum sludge [J]. Materials Science Research International, 2001, 7(1): 47-53. 
[6] 侯云芬,王栋民,李俏,路宏波. 水玻璃性能对粉煤灰基矿物聚合物的影响[J]. 硅酸盐学报,2008,36(1): 61-68.
[7] 丁锐. 水玻璃与粘土矿物之间表面反应的实验研究[J]. 岩土工程学报,1999(5): 334-337.
[8] Onuma Carmody, Ray Frost et al. Adsorption of hydrocar-bons on organo-clays-Implications for oil spill reme-diation [J]. Journal of Colloid and Interface Science , 2007(305): 17-24.
[9] 沈如,邹斌,齐琳琳. 丙烯酸钙改良软弱土质地基的研究[J]. 铁道建筑,2000(5): 10-12.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州