苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
超长复合型纤维水泥混凝土最佳配合比试验研究
The Experimental Research on Optimal Mix Proportion of Super-long Complex Fiber Cement Concrete
2011年第12期
超长复合型纤维;最佳配合比;正交试验;抗折强度;抗压强度
Super-long complex fiber; Optimal mix proportion; Orthogonal test; Flexural strength; Compressive strength
2011年第12期
1000-4637(2011)12-38-04
姜丽伟
哈尔滨工业大学,150090

姜丽伟

浏览量:
1000
摘 要:采用正交试验方法对超长复合型纤维水泥混凝土进行了最佳配合比试验研究。选择水灰比、砂率、纤维用量和减水剂用量四因素,每个因素四个水平进行试验,并通过极差、均值等分析方法对于正交试验结果进行了分析,得出了各因素及因素水平的变化对抗折、抗压强度的影响,最后确定了超长复合型水泥混凝土的最佳配合比。 Abstract: The experimental research of optimal mix proportion is carried out for super-long complex fiber cement concrete by using the orthogonal testing method. Four influencing factros including water-cement ratio, sand ratio, dosages of fiber and water reducing agent are chosen to conduct the experiment with four levels for each factor. Through different analysis methods such as the range and mean, the orthogonal results has been analyzed, and the effects of each factor and its level changing on the compressive and flexural strength are obtained, and finally the optimal mix proportion of super-long complex fiber cement concrete is determined.
英文名 : The Experimental Research on Optimal Mix Proportion of Super-long Complex Fiber Cement Concrete
刊期 : 2011年第12期
关键词 : 超长复合型纤维;最佳配合比;正交试验;抗折强度;抗压强度
Key words : Super-long complex fiber; Optimal mix proportion; Orthogonal test; Flexural strength; Compressive strength
刊期 : 2011年第12期
DOI :
文章编号 : 1000-4637(2011)12-38-04
基金项目 :
作者 : 姜丽伟
单位 : 哈尔滨工业大学,150090

姜丽伟

摘要
参数
结论
参考文献
引用本文

摘   要:采用正交试验方法对超长复合型纤维水泥混凝土进行了最佳配合比试验研究。选择水灰比、砂率、纤维用量和减水剂用量四因素,每个因素四个水平进行试验,并通过极差、均值等分析方法对于正交试验结果进行了分析,得出了各因素及因素水平的变化对抗折、抗压强度的影响,最后确定了超长复合型水泥混凝土的最佳配合比。

Abstract: The experimental research of optimal mix proportion is carried out for super-long complex fiber cement concrete by using the orthogonal testing method. Four influencing factros including water-cement ratio, sand ratio, dosages of fiber and water reducing agent are chosen to conduct the experiment with four levels for each factor. Through different analysis methods such as the range and mean, the orthogonal results has been analyzed, and the effects of each factor and its level changing on the compressive and flexural strength are obtained, and finally the optimal mix proportion of super-long complex fiber cement concrete is determined.

关键词:
超长复合型纤维;最佳配合比;正交试验;抗折强度;抗压强度
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
本研究以普通混凝土配比设计为基础,并通过对配合比的正交分析研究,得到了砂率、纤维掺量、水灰比、减水剂等因素对混凝土力学强度的影响关系。通过抗折强度与抗压强度试验,运用极差分析的试验方法,证明了水灰比与纤维掺量对抗折强度的影响最大,而纤维掺量对混凝土的抗压强度影响不明显。
主要考虑水泥混凝土路面对28d抗折强度的要求,综合权衡各正交因素对混凝土力学性能的影响和对和易性的影响以及混凝土的经济性,最终选定试验配合比为:用水量160kg/m3,石料质量1278 kg/m3,水灰比0.40,砂率34%,纤维掺量1.8kg/m3,即混凝土体积掺量分别为0.2%。减水剂并非影响混凝土力学性能的主要因素,因此,减水剂掺量以满足混凝土工作性为前提,选用掺量为0.3%。
[1] 霍俊芳,申向东,曹喜. 正交设计用于聚丙烯纤维混凝土抗冻性试验研究[J].混凝土,2006,(8):15-16.
[2] 柯开展,周瑞忠.短切碳纤维活性粉末混凝土最佳配合比试验研究[J].福州大学学报(自然科学版),34(4):560-565.
[3] 杨红辉,陈忠达,戴经梁.掺纤维水泥稳定碎石基层材料配合比研究[J].公路交通科技,2006,23(3):20-23.
[4] 李俊毅,叶国良,刘天伟.钢纤维和聚丙烯纤维混凝土配合比试验研究[J].中国港湾建设,2003,(1):9-13.
[5] 黄兆明,陈富强.基于正交设计方法的高性能沥青混凝土研究[J].山西建筑,2007,33(3):148-149.
[6] 王正友,廖明成,耿运贵.混杂纤维(钢/聚丙烯)高性能混凝土正交试验研究[J].焦作工学院学报(自然科学版),2003,22(1):15-20.
[7] 王建英.纤维混凝土配合比试验研究[J].山西交通科技,2006,(6):3-6.
[8] 梁磊,李艺,赵文,郭宪刚.受热前、后的纤维高性能混凝土弯曲性能的影响因素分析[J].混凝土,2007,(12):10-12.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州