苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
既有污水混凝土构筑物表层及内部混凝土腐蚀情况研究
Study on Corrosion of Surface and Internal Concrete of the Existing Sewage Concrete Structures
2019年第9期
污水混凝土;腐蚀深度;中性化;钙硅比;氯离子分布;微观形貌
Sewage concrete; Corrosion depth; Neutralization; Calcium silicon ratio; Chloride ion distribution; Micro-morphology
2019年第9期
10.19761/j.1000-4637.2019.09.006.04
上海市科委研发基地建设项目(18DZ2283400)。
沈贵阳1,刘远祥2,樊俊江3
1.上海市建筑科学研究院,201108;2.苏州混凝土水泥制品研究院有限公司,215004; 3.上海工业固体废弃物资源化利用工程技术研究中心,201108

沈贵阳1,刘远祥2,樊俊江3

沈贵阳,刘远祥,樊俊江.既有污水混凝土构筑物表层及内部混凝土腐蚀情况研究[J].混凝土与水泥制品,2019(9):6-9.

SHEN G Y,LIU Y X,FAN J J.Study on Corrosion of Surface and Internal Concrete of the Existing Sewage Concrete Structures[J].China Concrete and Cement Products,2019(9):6-9.

浏览量:
1000
摘 要:通过混凝土中性化深度测试并综合XRD、SEM、EDS、X-CT等微观测试手段对既有污水混凝土构筑物表层混凝土的腐蚀深度进行定量化表征。对污水混凝土构筑物内部混凝土力学性能、微观性能、内部钢筋锈蚀情况、氯离子含量分布进行测试,确认内部混凝土的腐蚀情况。通过污水水质分析推测污水混凝土构筑物腐蚀破坏的可能原因。结果表明,既有污水混凝土构筑物表面往下深度5 mm以内的混凝土受腐蚀较为严重,表面往下5~22 mm深度范围内的混凝土发生轻度的钙溶蚀,距腐蚀表面深度大于22 mm的内部混凝土未受腐蚀,污水构筑物表层混凝土受腐蚀的主要原因为有机物在微生物作用下形成的酸溶蚀。 Abstract: The corrosion depth of surface concrete of existing sewage concrete structures was quantitatively characterized by means of concrete neutralization depth test and micro-test methods such as XRD, SEM, EDS and X-CT. The mechanical properties, microscopic properties, corrosion state of steel bars and chloride ion content distribution of concrete inside were tested to confirm the inside concrete corrosion. The possible causes of corrosion damage of sewage concrete structures are inferred through the analysis of sewage water quality. The results show that the concrete of existing sewage concrete structures with a depth of less than 5 mm below the surface is corroded seriously. The concrete with a depth of 5~22 mm below the surface undergoes slight calcium corrosion. The concrete with a depth greater than 22 mm away from the corroded surface is not corroded. The main reason for the corrosion of sewage concrete is the acid corrosion caused by organic matter under the action of microorganisms
英文名 : Study on Corrosion of Surface and Internal Concrete of the Existing Sewage Concrete Structures
刊期 : 2019年第9期
关键词 : 污水混凝土;腐蚀深度;中性化;钙硅比;氯离子分布;微观形貌
Key words : Sewage concrete; Corrosion depth; Neutralization; Calcium silicon ratio; Chloride ion distribution; Micro-morphology
刊期 : 2019年第9期
DOI : 10.19761/j.1000-4637.2019.09.006.04
文章编号 :
基金项目 : 上海市科委研发基地建设项目(18DZ2283400)。
作者 : 沈贵阳1,刘远祥2,樊俊江3
单位 : 1.上海市建筑科学研究院,201108;2.苏州混凝土水泥制品研究院有限公司,215004; 3.上海工业固体废弃物资源化利用工程技术研究中心,201108

沈贵阳1,刘远祥2,樊俊江3

沈贵阳,刘远祥,樊俊江.既有污水混凝土构筑物表层及内部混凝土腐蚀情况研究[J].混凝土与水泥制品,2019(9):6-9.

SHEN G Y,LIU Y X,FAN J J.Study on Corrosion of Surface and Internal Concrete of the Existing Sewage Concrete Structures[J].China Concrete and Cement Products,2019(9):6-9.

摘要
参数
结论
参考文献
引用本文

摘   要:通过混凝土中性化深度测试并综合XRD、SEM、EDS、X-CT等微观测试手段对既有污水混凝土构筑物表层混凝土的腐蚀深度进行定量化表征。对污水混凝土构筑物内部混凝土力学性能、微观性能、内部钢筋锈蚀情况、氯离子含量分布进行测试,确认内部混凝土的腐蚀情况。通过污水水质分析推测污水混凝土构筑物腐蚀破坏的可能原因。结果表明,既有污水混凝土构筑物表面往下深度5 mm以内的混凝土受腐蚀较为严重,表面往下5~22 mm深度范围内的混凝土发生轻度的钙溶蚀,距腐蚀表面深度大于22 mm的内部混凝土未受腐蚀,污水构筑物表层混凝土受腐蚀的主要原因为有机物在微生物作用下形成的酸溶蚀。
Abstract: The corrosion depth of surface concrete of existing sewage concrete structures was quantitatively characterized by means of concrete neutralization depth test and micro-test methods such as XRD, SEM, EDS and X-CT. The mechanical properties, microscopic properties, corrosion  state of steel bars and chloride ion content distribution of concrete inside were tested to confirm the inside concrete corrosion. The possible causes of corrosion damage of sewage concrete structures are inferred through the analysis of sewage water quality. The results show that the concrete of existing sewage concrete structures with a depth of less than 5 mm below the surface is corroded seriously. The concrete with a depth of 5~22 mm below the surface undergoes slight calcium corrosion. The concrete with a depth greater than 22 mm away from the corroded surface is not corroded. The main reason for the corrosion of sewage concrete is the acid corrosion caused by organic matter under the action of microorganisms

关键词:
污水混凝土;腐蚀深度;中性化;钙硅比;氯离子分布;微观形貌
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)采用表层混凝土中性化深度测试并综合XRD、SEM、EDS、X-CT等微观测试手段可以对污水混凝土构筑物表层混凝土的腐蚀深度进行定量化的判断。
(2)既有污水混凝土表面往下深度4~5 mm范围内水化产物发生明显中性化,水化产物微结构受破坏不再完整,钙硅比明显偏低,区域混凝土密实度降低,混凝土受到了较为严重的腐蚀。表层往下深度5~22 mm范围内混凝土物相分析未发现明显Ca(OH)2峰,但水化产物结构基本完整,钙硅比在正常范围内,混凝土可能受到了轻微的钙溶蚀。深度大于22 mm的内部混凝土力学性能保持良好、钢筋未发生锈蚀、水化产物结构完整、物相分析发现明显Ca(OH)2峰、且氯离子含量分布稳定,混凝土基本未受到腐蚀。
(3)根据污水水样的测试分析,污水混凝土构筑物可排除氯离子侵蚀、硫酸盐侵蚀因素引起的破坏,其腐蚀破坏原因主要为含硫有机物在微生物作用下引起的酸腐蚀。

[1] 韩静云,张小伟,田永静,等.污水处理系统中混凝土结构的腐蚀现状调查及分析[J].混凝土,2000(9):52-54.
[2] 韩静云,张小伟,陈忠汉,等.混凝土排污管的微生物腐蚀[J].混凝土与水泥制品,2000(12):28-30.
[3] 耿健.混合水泥水化产物中C-S-H凝胶的半定量分析 [D].武汉:武汉理工大学,2005.
[4] 蒋慷.矿渣-粉煤灰-水泥复合材料的钙溶蚀过程研究 [D]. 南京:南京理工大学,2016.
[5] PARKER C.The corrosion of concrete isolation of a species of bacterium associated with the corrosion of concrete exposed to atmospheres containing hydrogen sul-phide[J].Exp BiolMed Sci,1945,23(3):14-17.
[6] 孔丽娟,韩梦迪,吴志刚.碳化对污水环境下混凝土性能的影响[J].硅酸盐学报,2018,46(8):1117-1125.

沈贵阳,刘远祥,樊俊江.既有污水混凝土构筑物表层及内部混凝土腐蚀情况研究[J].混凝土与水泥制品,2019(9):6-9.

SHEN G Y,LIU Y X,FAN J J.Study on Corrosion of Surface and Internal Concrete of the Existing Sewage Concrete Structures[J].China Concrete and Cement Products,2019(9):6-9.

 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州