苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
橡胶粉再生混凝土路用性能试验研究
Experimental Study on Road Performance of Recycled Concrete with Rubber Powder
2018年第8期
再生混凝土;橡胶粉;废弃混凝土;粒径;路用性能
Recycled concrete; Rubber powder; Waste concrete; Diameter; Pavement performante
2018年第8期
1000-4637(2018)08-97-04
甘肃省自然科学基金项目(1506RJZM322);甘肃省教育厅科研基金项目(2015A-151);陇东学院青年科技创新项目(XYZK1706)
杜 婷1,张斌伟1,郭志坚2
1.陇东学院土木工程学院,庆阳 745000;2.陇东学院电气工程学院,庆阳 745000

杜 婷1,张斌伟1,郭志坚2

浏览量:
1000
摘 要:在粗骨料(废弃混凝土)取代率为100%的再生混凝土中分别掺加2%、5%和8%的20目、40目和60目橡胶粉,按照相同的水灰比、砂率、强度等级配制了129个胶粉再生混凝土试件进行室内试验。结果表明,抗压强度随橡胶粉掺量的增加及粒径的减小而降低,抗折强度先增加后降低,而抗冲击韧性和抗冻性得到显著改善;再生混凝土中掺加5%的40目橡胶粉其路用性能最优。 Abstract: 2%,5% and 8% of rubber powder with 20mesh,40mesh and 60mesh are respectively added to the recycled concrete with 100% replacement of coarse aggregate,129 recycled concrete specimens are prepared for laboratory tests by the same water-cement ratio, sand rate and strength grade. The results show that the compressive strength decreases with the increase of mixed quantity and the decrease of the particle size rubber powder. The flexural strength increases first and then decreases, and the impact toughness and freezing resistance are improved significantly. The recycled aggregate concrete can reach the best pavement performance when mixed with 40 mesh, 5% rubber powder by comprehensive consideration.
英文名 : Experimental Study on Road Performance of Recycled Concrete with Rubber Powder
刊期 : 2018年第8期
关键词 : 再生混凝土;橡胶粉;废弃混凝土;粒径;路用性能
Key words : Recycled concrete; Rubber powder; Waste concrete; Diameter; Pavement performante
刊期 : 2018年第8期
DOI :
文章编号 : 1000-4637(2018)08-97-04
基金项目 : 甘肃省自然科学基金项目(1506RJZM322);甘肃省教育厅科研基金项目(2015A-151);陇东学院青年科技创新项目(XYZK1706)
作者 : 杜 婷1,张斌伟1,郭志坚2
单位 : 1.陇东学院土木工程学院,庆阳 745000;2.陇东学院电气工程学院,庆阳 745000

杜 婷1,张斌伟1,郭志坚2

摘要
参数
结论
参考文献
引用本文

摘   要:在粗骨料(废弃混凝土)取代率为100%的再生混凝土中分别掺加2%、5%和8%的20目、40目和60目橡胶粉,按照相同的水灰比、砂率、强度等级配制了129个胶粉再生混凝土试件进行室内试验。结果表明,抗压强度随橡胶粉掺量的增加及粒径的减小而降低,抗折强度先增加后降低,而抗冲击韧性和抗冻性得到显著改善;再生混凝土中掺加5%的40目橡胶粉其路用性能最优。

Abstract: 2%,5% and 8% of rubber powder with 20mesh,40mesh and 60mesh are respectively added to the recycled concrete with 100% replacement of coarse aggregate,129 recycled concrete specimens are prepared for laboratory tests by the same water-cement ratio, sand rate and strength grade. The results show that the compressive strength decreases with the increase of mixed quantity and the decrease of the particle size rubber powder. The flexural strength increases first and then decreases, and the impact toughness and freezing resistance are improved significantly. The recycled aggregate concrete can reach the best pavement performance when mixed with 40 mesh, 5% rubber powder by comprehensive consideration.

关键词:
再生混凝土;橡胶粉;废弃混凝土;粒径;路用性能
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)相比于天然骨料混凝土,再生混凝土的各项力学性能都有所降低。
(2)掺加胶粉的再生混凝土,抗压强度进一步降低,但抗折强度和抗冲击韧性增大。当掺量达到8%时,掺加60目橡胶粉的再生混凝土试件抗压强度降低幅度最大,比RC降低约30%,但抗冲击韧性提高40%。掺加20目橡胶粉时,抗折强度降低幅度最大,其值低于不加橡胶粉的再生混凝土,但相对于普通混凝土,其抗冲击韧性提高了23%。
(3)当采用20目橡胶粉时,其抗折强度随掺量的增加逐渐降低,采用40目和60目橡胶粉时,抗折强度先增加后降低,峰值出现在5%附近。
(4)对掺加20目和60目橡胶粉的再生混凝土试件,当掺量<5%时,抗冲击韧性的增幅较大,掺量超过5%后,增幅减小。而40目的橡胶粉再生混凝土试件增幅较均匀,对再生混凝土的抗冲击韧性有较大的提升。
(5)掺加40目橡胶粉的再生混凝土,其抗冻性能得到改善,随着掺量的增加,强度损失率减小,抗冻性能越好。冻融循环次数≤100次时,掺入橡胶粉的再生混凝土质量损失率比未加入橡胶粉时大,当冻融循环次数超过100次后,质量损失率不断增高,但与未掺入橡胶粉的再生混凝土相比,质量损失率降低,说明抗冻性较好。
(6)橡胶粉作为憎水材料加入再生混凝土中使其结构变紧密,提高了再生骨料的性能。综合考虑抗压强度和经济性的影响,在再生混凝土中掺加5%的40目橡胶粉时可得到较好的路用性能。
[1] 韩秀山.我国废旧橡胶利用现状及发展趋势[J].合成材料老化与应用,2002(1):43-45.
[2] 王显智,王子明,姜德义.再生骨料混凝土循环利用的试验研究[J].混凝土,2003(10):24-27.
[3] Kawano H. The state of using by-products in concrete in Japan and outline of JIS/TR on recycled concrete using recycled aggregate[C].Proceedings of the First FIB Congress, Osaka,Japan,2003:245-253.
[4] 邢振贤,周日农.再生混凝土的基本性能研究[J].华北水利水电学院学报,2001,19(2):30-32. 
[5] Rasheeduzzafar and Khan.Recycled concrete-a source of new aggregate[J].Cement Concrete and Aggregates(ASTM),2004,69(1):17-27.
[6] 马汉英,刘志欣.再生混凝土抗裂性能影响因素试验研究[J].天津建设科技,2010(4):10-12.
[7] Tsoumani A A,Barkoula N M,Matikas T E.Recycled aggregate as structural material[J].Waste Biomass Valorization,2015(5):883-890.
[8] Bendimerad A Z,Roziere E, Loukili A. Combined experimental methods to assess absorption rate of natural and recycled aggregates[J].Materials & Structures,2015,48(11):3557-3569.
[9] 杜婷.建筑垃圾再生骨料混凝土性能及强化试验研究[D].武汉:华中科技大学,2001.
[10] 王宝民,刘伟.国外掺废旧橡胶颗粒水泥混凝土研究进展[J].混凝土,2010(4):54-56.
[11] 吕晶,周天华,杜强,等.掺橡胶颗粒轻集料混凝土力学性能的试验研究[J].硅酸盐通报,2015,34(8):2077-2082.
[12] Guneyisi E,Gesoglu M,Ozturan T. Properties of rubberized concretes containing silica Fume[J].Cement and Concrete Research,2004(34):2309-2317.
[13] 龙广成,李宁,薛逸骅,等.冲击荷载作用下掺橡胶颗粒自密实混凝土的力学性能[J].硅酸盐学报,2016(8):1081-1090.
[14] 刘谨菡,王海龙,王岩,等.基于砂浆流动性的改性胶粉微观界面机理的研究[J].硅酸盐通报,2016(11):3770-3776.
[15] 刘源.包浆再生骨料混凝土的性能研究[D].西宁:宁夏大学,2009.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州