低速搅拌下高水胶比压浆料的制备及其性能研究

头部文案

发布时间：2020-01-06 00:00:00

全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊（光盘版）全文收录期刊

华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊



低速搅拌下高水胶比压浆料的制备及其性能研究

Study on Preparation and Properties of High Water-Binder Duct Grouts Under Low-speed Stirring

2020年第11期

压浆料；配合比；制备；性能；施工；低速搅拌

Duct grouts; Mix proportion; Preparation; Performance; Construction; Low-speed stirring

2020年第11期

10.19761/j.1000-4637.2020.11.030.05

国家重点研发计划项目（2016YFC0701904-3）；上海市科委社发项目（18DZ1205204）。

沈贵阳1，樊俊江2，於林锋3

1.上海市建筑科学研究院有限公司，上海 200032；2.上海工业固体废弃物资源化利用工程技术研究中心，上海 201108；3.上海市建筑科学研究院（集团）有限公司，上海 200000

沈贵阳1，樊俊江2，於林锋3

沈贵阳,樊俊江,於林锋.低速搅拌下高水胶比压浆料的制备及其性能研究[J].混凝土与水泥制品,2020(11):30-34.

SHEN G Y,FAN J J,YU L F.Study on Preparation and Properties of High Water-Binder Duct Grouts Under Low-speed Stirring[J].CHINA CONCRETE AND CEMENT PRODUCTS,2020(11):30-34.

浏览量:

1000

摘要：研究了低速搅拌、高水胶比下，减水剂、硅灰、粉煤灰及膨胀剂对压浆料的流动性、泌水率以及抗压强度等性能的影响规律，在此基础上优化了配合比，制备了普通低速搅拌下高水胶比压浆料。试验结果表明，在转速低于300 r/min、0.42高水胶比情况下，可以制备出初始流动度为25.5 s、不泌水、各项性能均满足实际工程应用要求的预应力孔道压浆材料。该制备技术在简化施工工艺的同时降低材料成本约231 元/吨，对促进预应力孔道压浆材料的技术改进具有重要的意义。 Abstract: The effects of high water-binder ratio, water reducing agent, silica fume, fly ash and expansion agent on the flowability, water bleeding rate and compressive strength of duct grouts under low-speed stirring were studied. On this basis, the mix proportion was optimized to prepare a high water-binder ratio duct grouts under ordinary low-speed stirring. The results show that under low-speed stirring at a speed lower than 300 r/min and a high water-binder ratio of 0.42, a prestressed channel grouting material with an initial fluidity of 25.5 s, no bleeding and performance that meets the requirements of practical engineering applications can be prepared. This preparation technology reduces the material cost by about 231 yuan/t while simplifying the construction process, which is of great significance to the technical improvement of the prestressed channel grouting material.

英文名 : Study on Preparation and Properties of High Water-Binder Duct Grouts Under Low-speed Stirring

刊期 : 2020年第11期

关键词 : 压浆料；配合比；制备；性能；施工；低速搅拌

Key words : Duct grouts; Mix proportion; Preparation; Performance; Construction; Low-speed stirring

刊期 : 2020年第11期

DOI : 10.19761/j.1000-4637.2020.11.030.05

文章编号 :

基金项目 : 国家重点研发计划项目（2016YFC0701904-3）；上海市科委社发项目（18DZ1205204）。

作者 : 沈贵阳1，樊俊江2，於林锋3

单位 : 1.上海市建筑科学研究院有限公司，上海 200032；2.上海工业固体废弃物资源化利用工程技术研究中心，上海 201108；3.上海市建筑科学研究院（集团）有限公司，上海 200000

沈贵阳1，樊俊江2，於林锋3

沈贵阳,樊俊江,於林锋.低速搅拌下高水胶比压浆料的制备及其性能研究[J].混凝土与水泥制品,2020(11):30-34.

SHEN G Y,FAN J J,YU L F.Study on Preparation and Properties of High Water-Binder Duct Grouts Under Low-speed Stirring[J].CHINA CONCRETE AND CEMENT PRODUCTS,2020(11):30-34.





摘要

参数

结论

参考文献

引用本文

Abstract: The effects of high water-binder ratio, water reducing agent, silica fume, fly ash and expansion agent on the flowability, water bleeding rate and compressive strength of duct grouts under low-speed stirring were studied. On this basis, the mix proportion was optimized to prepare a high water-binder ratio duct grouts under ordinary low-speed stirring. The results show that under low-speed stirring at a speed lower than 300 r/min and a high water-binder ratio of 0.42, a prestressed channel grouting material with an initial fluidity of 25.5 s, no bleeding and performance that meets the requirements of practical engineering applications can be prepared. This preparation technology reduces the material cost by about 231 yuan/t while simplifying the construction process, which is of great significance to the technical improvement of the prestressed channel grouting material.

关键词:

及其

the

and

材料

水胶

water-binder

low-speed

under

ratio

扫二维码用手机看

上一个

外包钢加固环形混凝土电杆受弯承载力计算方法研究

下一个

重晶石混凝土动态压缩性能研究

头部文案

低速搅拌下高水胶比压浆料的制备及其性能研究

相关文件