苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
钒钛磁铁尾矿微粉在混凝土中的应用研究
Application Study on Vanadium-titanium Magnet Tailings Fine Powder in Concrete
2019年第5期
钒钛磁铁尾矿;微粉;混凝土;掺合料;工作性;力学性能
Vanadium-titanium magnet tailings; Fine tailings powder; Concrete; Admixture; Workability; Mechanical property
2019年第5期
10.19761/j.1000-4637.2019.05.019.04
国家重点研发计划项目(2017YFC0703206)。
王春阳1,2,郑永超1,李 胜1,陈旭峰1,吝晓然1,3
1.固废资源化利用与节能建材国家重点实验室,北京 100041;2.承德冀东恒盛混凝土 有限公司,067000;3.河北工程大学,邯郸056006

王春阳1,2,郑永超1,李 胜1,陈旭峰1,吝晓然1,3

王春阳,郑永超,李胜,等.钒钛磁铁尾矿微粉在混凝土中的应用研究[J].混凝土与水泥制品,2019(5):19-21+30.

WANG C Y,ZHENG Y C,LI S,et al.Application Stud y on Vanadium-titanium Magnet Tailings Fine Powder in Concrete[J].China Concrete and Cement Products,2019(5):19-21+30.

浏览量:
1000
摘 要:利用钒钛磁铁尾矿经粉磨后制备的尾矿微粉,其活性指数低于粉煤灰和矿粉。使用比表面积约为450 m2/kg的钒钛磁铁尾矿粉进行了C30强度等级混凝土试配及性能测试。试验结果表明,钒钛磁铁尾矿微粉的替代率在45 kg以下时,对混凝土的工作性、力学性能及体积稳定性影响不大,且长龄期混凝土强度增量较高。 Abstract: The tailings fine powder was prepared by grinding the vanadium-titanium magnet tailings. The test results show that the activity index was lower than that of fly ash and slag powder, and the C30 concrete with tailings powder with a specific surface area of about 450 m2/kg was prepared and the properties tests are carried out. The test results show that when the replacement of tailings fine powder is less than 45 kg, it has little effect on workability, mechanical properties and stability of concrete, and the tailings fine powder can obviously improve the strength of concrete in the long-term.
英文名 : Application Study on Vanadium-titanium Magnet Tailings Fine Powder in Concrete
刊期 : 2019年第5期
关键词 : 钒钛磁铁尾矿;微粉;混凝土;掺合料;工作性;力学性能
Key words : Vanadium-titanium magnet tailings; Fine tailings powder; Concrete; Admixture; Workability; Mechanical property
刊期 : 2019年第5期
DOI : 10.19761/j.1000-4637.2019.05.019.04
文章编号 :
基金项目 : 国家重点研发计划项目(2017YFC0703206)。
作者 : 王春阳1,2,郑永超1,李 胜1,陈旭峰1,吝晓然1,3
单位 : 1.固废资源化利用与节能建材国家重点实验室,北京 100041;2.承德冀东恒盛混凝土 有限公司,067000;3.河北工程大学,邯郸056006

王春阳1,2,郑永超1,李 胜1,陈旭峰1,吝晓然1,3

王春阳,郑永超,李胜,等.钒钛磁铁尾矿微粉在混凝土中的应用研究[J].混凝土与水泥制品,2019(5):19-21+30.

WANG C Y,ZHENG Y C,LI S,et al.Application Stud y on Vanadium-titanium Magnet Tailings Fine Powder in Concrete[J].China Concrete and Cement Products,2019(5):19-21+30.

摘要
参数
结论
参考文献
引用本文
摘   要:利用钒钛磁铁尾矿经粉磨后制备的尾矿微粉,其活性指数低于粉煤灰和矿粉。使用比表面积约为450 m2/kg的钒钛磁铁尾矿粉进行了C30强度等级混凝土试配及性能测试。试验结果表明,钒钛磁铁尾矿微粉的替代率在45 kg以下时,对混凝土的工作性、力学性能及体积稳定性影响不大,且长龄期混凝土强度增量较高。
Abstract: The tailings fine powder was prepared by grinding the vanadium-titanium magnet tailings. The test results show that the activity index was lower than that of fly ash and slag powder, and the C30 concrete with tailings powder with a specific surface area of about 450 m2/kg was prepared and the properties tests are carried out. The test results show that when the replacement of tailings fine powder is less than 45 kg, it has little effect on workability, mechanical properties and stability of concrete, and the tailings fine powder can obviously improve the strength of concrete in the long-term. 
关键词:
钒钛磁铁尾矿;微粉;混凝土;掺合料;工作性;力学性能
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)随着粉磨时间的延长,钒钛铁尾矿粉磨效率降低,30 min左右达到粉磨平衡,但比表面积随着粉磨时间延长持续增长,激光粒度分析中位粒径D50由20.1 μm降至12.4 μm。
(2)随着比表面积的增长,钒钛铁尾矿微粉活性提高较少,低于矿渣粉和粉煤灰活性指数,作为掺合料主要起微集料和充填的作用。
(3)尾矿微粉掺入量在45 kg以下时,对各龄期抗压强度影响不大,且60 d长龄期抗压强度增进量较基准配合比高。掺入量达到60 kg时,对混凝土强度影响较大,同时混凝土收缩率略有增加,抗冻融循环性能则显著提高。
 
[1] 季馨婷,赵良,刘连文,等.基于CO2封存的盐酸浸取超贫钒钛磁铁矿尾矿实验研究[J].高校地质学报,2017,23(2):244-251.
[2] 郭毅霖.水泥基胶凝材料自收缩性能的研究[D].北京:北京工业大学,2006.

王春阳,郑永超,李胜,.钒钛磁铁尾矿微粉在混凝土中的应用研究[J].混凝土与水泥制品,2019(5):19-21+30.

WANG C Y,ZHENG Y C,LI S,et al.Application Stud y on Vanadium-titanium Magnet Tailings Fine Powder in Concrete[J].China Concrete and Cement Products,2019(5):19-21+30.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州