苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
陶粒预处理对轻骨料混凝土性能的影响
Effects of Ceramsite Pretreatment Methods on Performance of Lightweight Aggregate Concrete
2019年第4期
陶粒预处理;抗压强度;表观密度;导热系数;抗冻性;轻骨料混凝土
Ceramsite pretreatment; Compressive; Apparent density; Thermal conductivity; Antifreeze; Lightweight aggregate concrete
2019年第4期
10.19761/j.1000-4637.2019.04.024.05
辽宁省高等学校创新团队项目(LT2015024);沈阳市双百工程(重大科技研发)项目(Y17-0-039);沈阳市重点科技研发计划项目(17-48-2-00);辽宁省自然科学基金指导(20180550329)
刘 军1,2,段 超1,崔云鹏3,孙晓波4
1.沈阳建筑大学材料科学与工程学院,100168;2.沈阳理工大学材料科学与工程学院,110159; 3.大连理工大学建设工程学部,116024;4.沈阳建筑大学土木工程学院,100168

刘 军1,2,段 超1,崔云鹏3,孙晓波4

刘军,段超,崔云鹏,等.陶粒预处理对轻骨料混凝土性能的影响[J].混凝土与水泥制品,2019(4):24-28.

LIU J,DUAN C,CUI Y P,et al.Effects of Ceramsite Pretreatment Methods on Performance of Lightweight Aggregate Concrete[J].China Concrete and Cement Products,2019(4):24-28.

浏览量:
1000
摘 要:主要探究了五种不同预处理方法对轻骨料混凝土物理力学性能和热工性能的影响,并应用SEM观察预处理后过渡区界面的微观结构,研究了产生性能差异的原因。结果表明:预处理方法不同会对陶粒混凝土造成两种不同的破坏形式;与未处理相比,经预湿处理24 h的陶粒配置的混凝土可以提高混凝土抗压强度,表观密度降低了6.3%,且导热系数相对最小;经预处理后的陶粒制备混凝土会增加混凝土强度和质量损失率,并降低混凝土抗冻性能;SEM结果表明,陶粒预湿24 h处理配制的陶粒混凝土,陶粒与水泥石界面区结构致密,黏结较好,能够有效提高混凝土强度。 Abstract: The effects of five different pretreatment methods on the physical and mechanical properties and thermal properties of lightweight aggregate concrete were investigated. The microstructure of the interface in the transition zone after pretreatment was observed by SEM, and the reasons for the difference in performance was analyzed. The results show that the ceramsite concrete failure includes two forms of bond failure and splitting failure. The the compressive strength of concrete prepared by pre-wetting ceramsite for 24 h is higer than that of concrete prepared by untreated ceramsite, and the apparent density is reduced by 6.3% compared with the concrete prepared with untreated ceramsite, and the thermal conductivity is relatively minimum.The results of 25 freeze-thaw cycles show that the compressive strength loss rate and mass loss rate are the smallest and the frost resistance is the best. SEM observation shows that the ceramsite concrete prepared by pre-wetting ceramsite for 24 hours has a dense structure and good bond between ceramsite and cement stone, which could effectively improve the concrete strength.
英文名 : Effects of Ceramsite Pretreatment Methods on Performance of Lightweight Aggregate Concrete
刊期 : 2019年第4期
关键词 : 陶粒预处理;抗压强度;表观密度;导热系数;抗冻性;轻骨料混凝土
Key words : Ceramsite pretreatment; Compressive; Apparent density; Thermal conductivity; Antifreeze; Lightweight aggregate concrete
刊期 : 2019年第4期
DOI : 10.19761/j.1000-4637.2019.04.024.05
文章编号 :
基金项目 : 辽宁省高等学校创新团队项目(LT2015024);沈阳市双百工程(重大科技研发)项目(Y17-0-039);沈阳市重点科技研发计划项目(17-48-2-00);辽宁省自然科学基金指导(20180550329)
作者 : 刘 军1,2,段 超1,崔云鹏3,孙晓波4
单位 : 1.沈阳建筑大学材料科学与工程学院,100168;2.沈阳理工大学材料科学与工程学院,110159; 3.大连理工大学建设工程学部,116024;4.沈阳建筑大学土木工程学院,100168

刘 军1,2,段 超1,崔云鹏3,孙晓波4

刘军,段超,崔云鹏,等.陶粒预处理对轻骨料混凝土性能的影响[J].混凝土与水泥制品,2019(4):24-28.

LIU J,DUAN C,CUI Y P,et al.Effects of Ceramsite Pretreatment Methods on Performance of Lightweight Aggregate Concrete[J].China Concrete and Cement Products,2019(4):24-28.

摘要
参数
结论
参考文献
引用本文

摘   要:主要探究了五种不同预处理方法对轻骨料混凝土物理力学性能和热工性能的影响,并应用SEM观察预处理后过渡区界面的微观结构,研究了产生性能差异的原因。结果表明:预处理方法不同会对陶粒混凝土造成两种不同的破坏形式;与未处理相比,经预湿处理24 h的陶粒配置的混凝土可以提高混凝土抗压强度,表观密度降低了6.3%,且导热系数相对最小;经预处理后的陶粒制备混凝土会增加混凝土强度和质量损失率,并降低混凝土抗冻性能;SEM结果表明,陶粒预湿24 h处理配制的陶粒混凝土,陶粒与水泥石界面区结构致密,黏结较好,能够有效提高混凝土强度。

Abstract: The effects of five different pretreatment methods on the physical and mechanical properties and thermal properties of lightweight aggregate concrete were investigated. The microstructure of the interface in the transition zone after pretreatment was observed by SEM, and the reasons for the difference in performance was analyzed. The results show that the ceramsite concrete failure includes two forms of bond failure and splitting failure. The the compressive strength of concrete prepared by pre-wetting ceramsite for 24 h is higer than that of concrete prepared by untreated ceramsite, and the apparent density is reduced by 6.3% compared with the concrete prepared with untreated ceramsite, and the thermal conductivity is relatively minimum.The results of 25 freeze-thaw cycles show that the compressive strength loss rate and mass loss rate are the smallest and the frost resistance is the best. SEM observation shows that the ceramsite concrete prepared by pre-wetting ceramsite for 24 hours has a dense structure and good bond between ceramsite and cement stone, which could effectively improve the concrete strength.

关键词:
陶粒预处理;抗压强度;表观密度;导热系数;抗冻性;轻骨料混凝土
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)陶粒混凝土的破坏基本上分为两种情况。一种为陶粒和水泥石界面黏结破坏;另一种为粗骨料劈裂破坏。通过对比未处理陶粒与其他五种预处理方法,发现在生产陶粒混凝土时对陶粒进行预湿24 h处理,与未处理相比,抗压强度会有提高,混凝土破坏形式为粗骨料劈裂破坏。
(2)陶粒经过破碎处理制成的陶粒混凝土抗压强度最低,抗冻性与未处理陶粒制成的混凝土的抗冻性相当,表观密度和导热系数较大,陶粒破碎面与水泥石界面分割清晰,黏骨接相对紧密。由于陶粒结构破坏,使混凝土承载力降低,其他各项性能均较差,所以在生产中应避免使用破碎的陶粒。
(3)陶粒未处理、预湿1 h处理、预湿24 h处理制成的陶粒混凝土抗冻性能、表观密度和导热系数逐渐降低,而预湿24 h处理制成的陶粒混凝土抗压强度最大。所以在陶粒混凝土生产中可以对陶粒进行预湿处理,制成的陶粒混凝土强度和节能效果最好,表观密度与未处理陶粒配制混凝土相比也有所降低,粗骨料与水泥石界面黏接最为紧密,然而抗冻性能相对较差,但仍能满足要求。
(4)陶粒预湿24 h包裹磷酸镁水泥以及陶粒预湿24 h包裹普通硅酸盐水泥制成的混凝土,前者仅抗压强度优于后者。但是其他各项性能都次于预湿24 h处理方法,同时在生产加工繁琐,不适于生产实践中。
[1] 贾兴文,吴洲,何兵,等.陶粒预湿处理对陶粒泡沫混凝土物理力学性能的影响[J].材料导报,2013(6):131-135.
[2] 王向阳,潘志华,邢亚兵,等.陶粒表面预处理对陶粒泡沫混凝土性能的影响[J].材料导报,2016(7):130-134.
[3] 赵洪春.陶粒预湿处理时间对陶粒泡沫混凝土物理力学性能的影响[J].砖瓦,2014(6):39.
[4] 王海涛,王立成.钢纤维高强轻骨料混凝土弯曲韧性与抗冲击性能[J].建筑材料学报,2013,16(6):1083-1085.
[5] 王昭恩,冯绍颖,林荣斌,等.陶粒混凝土配制及强度试验研究[J].混凝土与水泥制品,2017(10):70-72.
[6] 诸雪青.粉煤灰陶粒混凝土配合比优化设计及综合应用性能[D].青岛:青岛理工大学,2016.
[7] 刘喜,吕贝贝,刘全威,等.高强轻骨料陶粒混凝土配合比及强度影响因素试验研究[J].硅酸盐通报,2014(4):847-852.
[8] 蒋玉川,霍达,滕海文,等.页岩陶粒混凝土高温性能特征研究[J].建筑材料学报,2013,16(5):888-893.
[9] Camiopneg,Lidia La Mendola.Behavior in compression of light-weight fiber reinforced concrete confined with transverse steel reinforcement[J].Cement and Concrete Composites,2004(6):645-656.
[10] 史永建,白会人,李金奎.粉煤灰陶粒混凝土抗冻性能研究[J].混凝土,2016(11):86-89.
[11] 李博.冻融循环下高强度陶粒混凝土的耐久性能研究[J].新型建筑材料,2017(8):93-96.
[12] P.P.Fedorov,A.A.Luginin,S.V.Kuznetsov,et al.Preparation and properties of methylcellulose/nanocellulose/СаF2:Но polymeri norganic compositefilms for two micron radiation visualiz-ers[J].Journal of Fluorine Chemistry,2017:202.
[13] 郑秀华,袁杰.预湿程度对页岩陶粒混凝土强度和抗冻性的影响[C].第十一届全国轻骨料及轻骨料混凝土学术讨论会论文集,2012:265-269.
[14] Cusson D,Hooqeveen T.Internal curing of high-performance concrete with presoaked fine lightweight aggregate for prevention of autogenous shrink-age cracking[J]. Cement and Concrete Research,2008,38(6):757-765.
[15] Hossain K M A,Ahmed S, Lachemi M,et al.Lightweight concrete incorporating pumice based blended cement and aggreg-ate,Mechanical and durability characteristics[J].Construction and Building Materials,2011,25(3):1186-1195.
[16] 方明伟,王丹,殷玲,等.呼伦贝尔地区炉渣类陶粒混凝土砌块抗冻性的研究[J].呼伦贝尔学院学报,2018(2):137-141.
[17] 李振龙,李颖,吴春丽.再生细骨料制备陶粒混凝土抗压强度与导热系数试验研究[J].材料研究与应用,2017(3):6-9.
[18] 段军,丁建彤,郭玉顺.1000~1400 级轻骨料混凝土的密度与强度及保温性能的关系[J].墙材革新与建筑节能,2005(11):44-47.
[19] 刘阳杰,吴玮,陈锥,等.碎石型页岩陶粒混凝土的密度、强度与导热系数的相关性研究[J].福建建材,2014(10):11-13.
[20] Ramazan Demirboga,Rüstem Gül.The effects of expanded perlite aggregate,silica fume and fly ash on the thermal conductivity of lightweight concrete[J]. Cement and Concrete Research,2003, Elsevie.
[21] 刘卫东,田波.混凝土导热系数试验研究[J].中外公路,2012(1):226-229.

刘军,段超,崔云鹏,.陶粒预处理对轻骨料混凝土性能的影响[J].混凝土与水泥制品,2019(4):24-28.

LIU J,DUAN C,CUI Y P,et al.Effects of Ceramsite Pretreatment Methods on Performance of Lightweight Aggregate Concrete[J].China Concrete and Cement Products,2019(4):24-28.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州