苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
混凝土用聚乙烯醇纤维和聚丙烯纤维耐碱性能对比分析
Comparative Analysis on Alkali Resistance Properties of Polyvinyl Alcohol Fiber and Polypropylene Fiber for Concrete
2019年第5期
混凝土;聚乙烯醇纤维;聚丙烯纤维;耐碱性能;微观形貌
Concrete; Polyvinyl alcohol fiber; Polypropylene fiber; Alkali resistance; Microscopic appearance
2019年第5期
10.19761/j.1000-4637.2019.05.054.05
国家自然科学基金项目(51578479、51708483);国家重点研发计划项目(2016YFB0303104)。
王天琪1,杨鼎宜1,2,骆静静3,沈娟华3
1.扬州大学建筑科学与工程学院,225127;2.扬州大学绿色建筑材料研究所,225127; 3.苏州混凝土水泥制品研究院有限公司,215004

王天琪1,杨鼎宜1,2,骆静静3,沈娟华3

王天琪,杨鼎宜,骆静静,等.混凝土用聚乙烯醇纤维和聚丙烯纤维耐碱性能对比分析[J].混凝土与水泥制品,2019(5):54-58.

WANG T Q,YANG D Y,LUO J J,et al.Comparative Analysis on Alkali Resistance Properties of Polyvinyl Alcohol Fiber and Polypropylene Fiber for Concrete[J].China Concrete and Cement Products,2019(5):54-58.

浏览量:
1000
摘 要:为了探究聚乙烯醇(PVA)纤维和聚丙烯(PP)纤维应用于混凝土中的稳定性,配制了不同浓度的NaOH溶液来模拟混凝土的碱性环境,同时采用加速腐蚀的方法对两种纤维进行碱溶液腐蚀处理,分别测试不同时间段两种纤维的直径和力学性能,并通过电镜观察纤维的表面变化情况。试验结果表明,随着浸泡时间的延长,两种纤维的直径都有所增加,强度都逐渐减小,但PP纤维的耐碱性能优于PVA纤维;碱溶液浓度越高,对纤维的腐蚀就越严重。微观形貌分析表明,相同条件下,PVA纤维比PP纤维受腐蚀更为严重。 Abstract: In order to investigate the stability of polyvinyl alcohol fiber and polypropylene fiber used in concrete, different concentrations of NaOH solution were formulated to simulate the alkaline environment of the concrete, and both fibers were subjected to alkaline solution corrosion treatment by accelerated corrosion. The diameters and mechanical properties of the two fibers were tested at different time periods, and the surface changes of the fibers were observed by electron microscopy. The test results show that as the soaking time prolonged, the diameters of both fibers increased, and the strength decreased gradually. However, the alkali resistance of polypropylene fibers was superior to that of polyvinyl alcohol fibers the higher the concentration of the alkali solution was, the more serious the corrosion. Micromorphology analysis shows that under the same conditions, PVA fibers are more corrosive than PP fibers.
英文名 : Comparative Analysis on Alkali Resistance Properties of Polyvinyl Alcohol Fiber and Polypropylene Fiber for Concrete
刊期 : 2019年第5期
关键词 : 混凝土;聚乙烯醇纤维;聚丙烯纤维;耐碱性能;微观形貌
Key words : Concrete; Polyvinyl alcohol fiber; Polypropylene fiber; Alkali resistance; Microscopic appearance
刊期 : 2019年第5期
DOI : 10.19761/j.1000-4637.2019.05.054.05
文章编号 :
基金项目 : 国家自然科学基金项目(51578479、51708483);国家重点研发计划项目(2016YFB0303104)。
作者 : 王天琪1,杨鼎宜1,2,骆静静3,沈娟华3
单位 : 1.扬州大学建筑科学与工程学院,225127;2.扬州大学绿色建筑材料研究所,225127; 3.苏州混凝土水泥制品研究院有限公司,215004

王天琪1,杨鼎宜1,2,骆静静3,沈娟华3

王天琪,杨鼎宜,骆静静,等.混凝土用聚乙烯醇纤维和聚丙烯纤维耐碱性能对比分析[J].混凝土与水泥制品,2019(5):54-58.

WANG T Q,YANG D Y,LUO J J,et al.Comparative Analysis on Alkali Resistance Properties of Polyvinyl Alcohol Fiber and Polypropylene Fiber for Concrete[J].China Concrete and Cement Products,2019(5):54-58.

摘要
参数
结论
参考文献
引用本文
摘   要:为了探究聚乙烯醇(PVA)纤维和聚丙烯(PP)纤维应用于混凝土中的稳定性,配制了不同浓度的NaOH溶液来模拟混凝土的碱性环境,同时采用加速腐蚀的方法对两种纤维进行碱溶液腐蚀处理,分别测试不同时间段两种纤维的直径和力学性能,并通过电镜观察纤维的表面变化情况。试验结果表明,随着浸泡时间的延长,两种纤维的直径都有所增加,强度都逐渐减小,但PP纤维的耐碱性能优于PVA纤维;碱溶液浓度越高,对纤维的腐蚀就越严重。微观形貌分析表明,相同条件下,PVA纤维比PP纤维受腐蚀更为严重。
Abstract: In order to investigate the stability of polyvinyl alcohol fiber and polypropylene fiber used in concrete, different concentrations of NaOH solution were formulated to simulate the alkaline environment of the concrete, and both fibers were subjected to alkaline solution corrosion treatment by accelerated corrosion. The diameters and mechanical properties of the two fibers were tested at different time periods, and the surface changes of the fibers were observed by electron microscopy. The test results show that as the soaking time prolonged, the diameters of both fibers increased, and the strength decreased gradually. However, the alkali resistance of polypropylene fibers was superior to that of polyvinyl alcohol fibers the higher the concentration of the alkali solution was, the more serious the corrosion. Micromorphology analysis shows that under the same conditions, PVA fibers are more corrosive than PP fibers. 
关键词:
混凝土;聚乙烯醇纤维;聚丙烯纤维;耐碱性能;微观形貌
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)PVA纤维和PP纤维在不同浓度碱溶液浸泡下,纤维直径均逐渐增加,溶胀率增大,强度随着时间的延长逐渐减小,纤维被NaOH溶液腐蚀,且加温浸泡下,溶液浓度越高,纤维被腐蚀的就越严重,尤其是1 mol/L NaOH溶液浸泡后,相比其他浓度浸泡下的两种合成纤维,强度下降得最快,纤维腐蚀也最为明显。
(2)从PVA纤维和PP纤维溶胀率变化、强度保留率变化以及微观观测图看,同一腐蚀时间情况下,PVA纤维在各个浓度的NaOH溶液中受到的破坏均大于PP纤维;同一NaOH溶液浓度下,PVA纤维强度下也比PP纤维更快。PVA纤维在1 mol/L NaOH溶液中浸泡240 h后,强度保留率为72.7%;同一条件下,PP纤维的强度保留率为85.3%,即PP纤维的耐碱性能优于PVA纤维。
(3)碱溶液处理对二种合成纤维而言均是一个从外到内逐层腐蚀的过程。碱溶液首先腐蚀的是纤维的表面和内部杂质,之后深入到纤维内部腐蚀纤维结构缺陷部分,使其出现凹凸不平的沟槽。同一浸泡时间下,PVA纤维的腐蚀情况要比PP纤维严重,出现了大面积的结构缺陷,有明显的分层剥离现象,而PP纤维内部只有一小部分受到腐蚀,其余部分完好。因此,相比PVA纤维,PP纤维能更好地在碱性环境中保持良好的稳定性。
[1] 周明耀,杨鼎宜,汪洋.合成纤维混凝土材料的发展与应用[J].水利与建筑工程学报,2003(4):1-4.
[2] 王晓飞.高强高性能混凝土配合比优化设计[D].西安:西安建筑科技大学,2012.
[3] 蒋家奋,曹永康.展望21世纪混凝土科学技术[J].混凝土与水泥制品,2000(1):6-7.
[4] 王海波.聚乙烯醇纤维(维纶)增强砂浆性能的研究[D].北京:北京工业大学,2003.
[5] 杨雯雯.纤维混凝土力学性能及耐久性能试验研究[D].济南:山东大学,2012.
[6] 陈润锋,张国防,顾国芳.我国合成纤维混凝土研究与应用现状[J].建筑材料学报,2001(2):167-173.
[7] 曹诚,刘兰强.关于聚丙烯纤维对混凝土性能影响的几点认识[J].混凝土,2000(9):49-51.
[8] 邓宗才,李建辉,刘国栋.混杂粗纤维增强混凝土力学特性试验研究[J].混凝土,2006(8):50-55.
[9] 沈荣熹,崔琪,李清海.新型纤维增强水泥基复合材料[M]. 北京:中国建材工业出版社,2004.
[10] 马佳晨,张炉青,张学旭,等.改性水泥基材料用聚乙烯醇纤维耐碱性能研究[J].中国粉体技术,2015,21(2):61-63.
[11] 高鹏锟,胡微微,赵党锋,等.聚丙烯、玄武岩纤维和耐碱玻璃纤维耐碱性能对比分析[J].天津纺织科技,2011(1):19-21,24.
[12] 刘光云.改性聚丙烯纤维提高混凝土性能的作用机理[J]. 安徽建筑,2005(1):99-100.
[13] 孟志良,吴仲兵,钱觉时.大掺量粉煤灰混凝土的孔隙液相碱度[J].重庆建筑大学学报,1999,21(1):27-28.
[14] 刘森,李发学,俞建勇,等.Richcel纤维的耐碱性能研究[J]. 纺织科学研究,2004(2):12-15,44.
[15] Chae D.W., Choi K.R., Kim B. C., et al. Effect of Cellulose Pulp on the Mercerizing Behavior and Physical Properties of Lyocell Fibers[J].Textile Res.J,2003,73(6):541-545.
[16] 詹怀宇.纤维素化学与物理[M].北京:科学出版社,2005.
[17] 郑明霞,李来庆,郑明月,等.碱处理对玉米秸秆纤维素结构的影响[J].环境科学与技术,2012,35(6):27-31.
[18] 鲁杰,石淑兰,杨汝男,等.纤维素酶酶解苇浆纤维微观结构和结晶结构的变化[J].中国造纸学报,2005,20(2):85-90.
[19] 何艳峰,李秀金,方文杰,等.NaOH固态预处理对稻草中纤维素结构特性的影响[J].可再生能源,2007,25(5):31-34.
[20] 王晓刚,毛新奇,赵铁军.聚乙烯醇纤维水泥基复合材料[J].青岛建筑工程学院学报,2004(4):28-31.
[21] 赵波,龙跃,张良进,等.高炉渣纤维耐碱性及其对混凝土性能的影响[J].硅酸盐通报,2016,35(4):1240-1244.

王天琪,杨鼎宜,骆静静,.混凝土用聚乙烯醇纤维和聚丙烯纤维耐碱性能对比分析[J].混凝土与水泥制品,2019(5):54-58.

WANG T Q,YANG D Y,LUO J J,et al.Comparative Analysis on Alkali Resistance Properties of Polyvinyl Alcohol Fiber and Polypropylene Fiber for Concrete[J].China Concrete and Cement Products,2019(5):54-58.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州