苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
碱激发矿粉-粉煤灰混凝土耐久性能试验研究
Experimental Study on Durability of Alkali-activated Mineral Powder and Fly Ash Concrete
2022年第9期
机制砂碱激发混凝土;蒸养制度;收缩开裂;耐久性能
Manufactured sand alkali-activated concrete(MAAC); Steaming method; Shrinkage cracking; Durability
2022年第9期
10.19761/j.1000-4637.2022.09.095.04
任 君1,王允波2,徐伟伟2,张思雨2,王玉璞2,王 腾2
1.青建集团股份公司,山东 青岛 266001;2.青岛青建新型材料集团有限公司,山东 青岛 266109

任 君1,王允波2,徐伟伟2,张思雨2,王玉璞2,王 腾2

任君,王允波,徐伟伟,等.碱激发矿粉-粉煤灰混凝土耐久性能试验研究[J].混凝土与水泥制品,2022(9):95-98.

REN J,WANG Y B,XU W W,et al.Experimental Study on Durability of Alkali-activated Mineral Powder and Fly Ash Concrete[J].China Concrete and Cement Products,2022(9):95-98.

浏览量:
1000
摘   要:研究了激发剂模数、养护方式和粉煤灰掺量对机制砂碱激发混凝土(MAAC)耐久性能的影响。结果表明:与20 ℃标养相比,60 ℃蒸养MAAC的收缩率降低明显,耐久性能增强;掺入20%粉煤灰后,MAAC的收缩性能有所改善,抗硫酸盐侵蚀性能有所减弱,但在蒸养条件下,掺入20%粉煤灰可以在一定程度上提高MAAC的抗氯离子侵蚀能力;随着碱激发剂模数由2.0降至1.8,MAAC的耐久性能有所增强。 Abstract: The effects of activator modulus, curing method and fly ash content on the durability of manufactured sand alkali-activated concrete(MAAC) were studied. The results show that compared with the standard curing at 20 ℃, the shrinkage rate of MAAC in steam curing at 60 ℃ is significantly reduced, and the durability is enhanced. After adding 20% fly ash, the shrinkage performance of MAAC is improved, the resistance to sulfate corrosion is weakened, but under steam curing conditions, adding 20% fly ash can improve the chloride ion corrosion resistance of MAAC to a certain extent. The durability of MAAC is enhanced with the decrease of alkali activator modulus from 2.0 to 1.8.
英文名 : Experimental Study on Durability of Alkali-activated Mineral Powder and Fly Ash Concrete
刊期 : 2022年第9期
关键词 : 机制砂碱激发混凝土;蒸养制度;收缩开裂;耐久性能
Key words : Manufactured sand alkali-activated concrete(MAAC); Steaming method; Shrinkage cracking; Durability
刊期 : 2022年第9期
DOI : 10.19761/j.1000-4637.2022.09.095.04
文章编号 :
基金项目 :
作者 : 任 君1,王允波2,徐伟伟2,张思雨2,王玉璞2,王 腾2
单位 : 1.青建集团股份公司,山东 青岛 266001;2.青岛青建新型材料集团有限公司,山东 青岛 266109

任 君1,王允波2,徐伟伟2,张思雨2,王玉璞2,王 腾2

任君,王允波,徐伟伟,等.碱激发矿粉-粉煤灰混凝土耐久性能试验研究[J].混凝土与水泥制品,2022(9):95-98.

REN J,WANG Y B,XU W W,et al.Experimental Study on Durability of Alkali-activated Mineral Powder and Fly Ash Concrete[J].China Concrete and Cement Products,2022(9):95-98.

摘要
参数
结论
参考文献
引用本文

摘   要:研究了激发剂模数、养护方式和粉煤灰掺量对机制砂碱激发混凝土(MAAC)耐久性能的影响。结果表明:与20 ℃标养相比,60 ℃蒸养MAAC的收缩率降低明显,耐久性能增强;掺入20%粉煤灰后,MAAC的收缩性能有所改善,抗硫酸盐侵蚀性能有所减弱,但在蒸养条件下,掺入20%粉煤灰可以在一定程度上提高MAAC的抗氯离子侵蚀能力;随着碱激发剂模数由2.0降至1.8,MAAC的耐久性能有所增强。

Abstract: The effects of activator modulus, curing method and fly ash content on the durability of manufactured sand alkali-activated concrete(MAAC) were studied. The results show that compared with the standard curing at 20 ℃, the shrinkage rate of MAAC in steam curing at 60 ℃ is significantly reduced, and the durability is enhanced. After adding 20% fly ash, the shrinkage performance of MAAC is improved, the resistance to sulfate corrosion is weakened, but under steam curing conditions, adding 20% fly ash can improve the chloride ion corrosion resistance of MAAC to a certain extent. The durability of MAAC is enhanced with the decrease of alkali activator modulus from 2.0 to 1.8.

扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)与20 ℃标养相比,采用60 ℃蒸养可以有效降低MAAC的收缩率,提高MAAC的抗氯离子渗透性能和抗硫酸盐侵蚀能力。
(2)掺入20%的粉煤灰可在一定程度上提高MAAC的收缩性能,但对MAAC的抗硫酸盐侵蚀性能不利;但在蒸养条件下,掺入20%的粉煤灰可在一定程度上提高MAAC的抗氯离子渗透性能。
(3)与激发剂模数为2.0的试件相比,激发剂模数为1.8的试件收缩性能和抗氯离子渗透性能更好。
(4)综合考虑,当粉煤灰掺量为20%、激发剂模数为1.8、采用60 ℃蒸养时,MAAC的收缩性能较好,抗氯离子渗透性能和抗硫酸盐侵蚀能力良好。

[1] 闵佳鑫.“双碳”战略下绿色建造需先行[N].中国铁道建筑报,2021-10-16(21).
[2] 张时聪,王珂,杨芯岩,徐伟.建筑部门碳达峰碳中和排放控制目标研究[J].建筑科学,2021,37(8):189-198.
[3] 丁美荣.水泥行业碳排放现状分析与减排关键路径探讨[J].中国水泥,2021(7):46-49.
[4] 李琛,董诗婕.碳达峰碳中和背景下水泥行业结构调整之路[J].中国水泥,2021(9):10-15.
[5] AMER I,KOHAIL M,EL-FEKY M S,et al.A Review on Alkali-activated Slag Concrete[J].Ain Shams Engineering Journal,2021,12(2):1475-1499.
[6] 丁锐,何月,李星辰.碱激发胶凝材料的研究现状[J].混凝土与水泥制品,2021(7):7-11.
[7] 邱洪强.机制砂颗粒形状及石粉含量对混凝土性能的影响[D].深圳:深圳大学,2015.
[8] 中华人民共和国住房和城乡建设部.普通混凝土长期性能和耐久性能试验方法标准:GB/T 50082—2009[S].北京:中国建筑工业出版社,2009.
[9] YE H L,RADLINSKA A.Shrinkage Mechanisms of Alkali-activated Slag[J].Cement and Concrete Research,2016,88:126-135.
[10] CASTEL A,FOSTER S J,NG T,et al.Creep and Drying Shrinkage of a Blended Slag and Low Calcium Fly Ash Geopolymer Concrete[J].Materials and Structures,2016,49:1619-1628.
[11] YANG T,ZHU H J,ZHANG Z H.Influence of Fly Ash on the Pore Structure and Shrinkage Characteristics of Metakaolin-based Geopolymer Pastes and Mortars[J].Construction and Building Materials,2017,153:284-293.
[12] CHI M,HUANG R.Binding Mechanism and Properties of Alkali-activated Fly Ash/Slag Mortars[J].Construction and Building Materials,2013,40:291-298.
[13] 赵庆新,孙伟,郑克仁,等.粉煤灰掺量对高性能混凝土徐变性能的影响及其机理[J].硅酸盐学报,2006(4):446-451.
[14] HOJATI M,RADLINSKA A.Shrinkage and Strength Development of Alkali-activated Fly Ash-slag Binary Cements[J].Construction and Building Materials,2017,150:808-816.
[15] 廖明辉,刘开帝.碱激发高钙粉煤灰地质聚合物的强度特性[J].珪酸盐通报,2015(8):2167-2170,2176.
[16] 孙明,鲍麒,丁贵军,等.粉煤灰对混凝土碳化及氯离子侵蚀规律的影响[J].公路,2021,66(8):295-299.
[17] 马倩敏,黄丽萍,牛治亮,等.碱激发剂浓度及模数对碱矿渣胶凝材料抗压性能及水化产物的影响研究[J].硅酸盐通报,2018,37(6):2002-2007.
[18] 黄振育,于小华.碱矿渣混凝土与水泥混凝土的抗硫酸盐侵蚀性能研究[J].混凝土与水泥制品,2021(9):21-24.
[19] 金宇,董志君,STEPHAN D,等.侵蚀介质作用下碱激发矿渣混凝土耐久性试验研究[J].混凝土,2021(9):82-85.
[20] 贺北斗.碱激发粉煤灰矿渣胶凝材料在硫酸盐侵蚀下的性能研究[D].西安:长安大学,2020.

任君,王允波,徐伟伟,.碱激发矿粉-粉煤灰混凝土耐久性能试验研究[J].混凝土与水泥制品,2022(9):95-98.

REN J,WANG Y B,XU W W,et al.Experimental Study on Durability of Alkali-activated Mineral Powder and Fly Ash Concrete[J].China Concrete and Cement Products,2022(9):95-98.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州