养护温度与脱硫石膏掺量对RPC性能的影响_《混凝土与水泥制品》杂志社

头部文案

发布时间：2020-01-06 00:00:00

全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊（光盘版）全文收录期刊

华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊



养护温度与脱硫石膏掺量对RPC性能的影响

Effect of curing temperature and desulfurization gypsum content on performance of RPC

2024年第7期

活性粉末混凝土（RPC）；脱硫石膏；养护温度；强度；膨胀性能；机理分析

Reactive powder concrete(RPC); Desulfurization gypsum; Curing temperature; Strength; Expansion property; Mechanism analysis

2024年第7期

10.19761/j.1000-4637.2024.07.083.06

四川省科技计划项目（2023YFSY0019）。

王旭1，付建鹏1，金冰欣2，朱斌1，武双磊2，*，徐迅3

1.桐庐宏基源混凝土有限公司，浙江杭州 311502；2.浙江大学材料科学与工程学院，浙江杭州 310027；3.西南科技大学土木工程与建筑学院，四川绵阳 621010

王旭1，付建鹏1，金冰欣2，朱斌1，武双磊2，*，徐迅3

王旭,付建鹏,金冰欣,等.养护温度与脱硫石膏掺量对RPC性能的影响[J].混凝土与水泥制品,2024(7):83-88.

WANG X,FU J P,JIN B X,et al.Effect of curing temperature and desulfurization gypsum content on performance of RPC[J].China Concrete and Cement Products,2024(7):83-88.

浏览量:

1000

摘要：以普通硅酸盐水泥、脱硫石膏、矿渣等制备了活性粉末混凝土（RPC），研究了养护温度（20、45、70 ℃）和脱硫石膏掺量（2%~7%）对RPC强度和膨胀率的影响，并进行了XRD和SEM分析。结果表明：当养护温度为20 ℃时，随着脱硫石膏掺量的增加，试件的28 d抗折与抗压强度均先增大后减小；当养护温度为45 ℃时，随着脱硫石膏掺量的增加，试件的28 d抗折强度增大，28 d抗压强度先增大后减小；当养护温度为70 ℃时，试件的28 d抗折与抗压强度均增大；当脱硫石膏掺量相同时，随着养护温度的提高，试件的28 d抗折与抗压强度基本呈增大趋势；脱硫石膏掺量越高，试件的膨胀率越大；养护温度越高，试件趋于稳定时的膨胀率越低；在RPC中掺入适量石膏，并辅以适宜的养护温度，可有效加快水泥和矿渣的水化进程，生成钙矾石，进而改善RPC的强度和膨胀性能。 Abstract: Reactive powder concrete(RPC) was prepared by using ordinary Portland cement, desulfurization gypsum, slag, etc. The effects of curing temperature (20, 45, 70 ℃) and desulfurization gypsum content (2%~7%) on the strength and expansion rate of RPC were studied, and XRD and SEM analysis were conducted. The results show that when the curing temperature is 20 ℃, with the increase of desulfurization gypsum content, the 28 d flexural strength and compressive strength of the specimen first increase and then decrease. When the curing temperature is 45 ℃, with the increase of desulfurization gypsum content, the 28 d flexural strength of the specimen increases and the 28 d compressive strength first increases and then decreases. When the curing temperature is 70 ℃, the 28 d flexural strength and compressive strength of the specimen increase. When the content of desulfurization gypsum is the same, with the increase of curing temperature, the 28 d flexural strength and compressive strength of the specimen basically show an increasing trend. The higher the content of desulfurization gypsum, the greater the expansion rate of the specimen. The higher the curing temperature, the lower the expansion rate of the specimen when it tends to stabilize. Adding an appropriate content of gypsum to RPC, accompanied by an appropriate curing temperature can effectively promote the hydration process of cement and slag, generate ettringite, and improve the strength and expansion properties of RPC.

英文名 : Effect of curing temperature and desulfurization gypsum content on performance of RPC

刊期 : 2024年第7期

关键词 : 活性粉末混凝土（RPC）；脱硫石膏；养护温度；强度；膨胀性能；机理分析

Key words : Reactive powder concrete(RPC); Desulfurization gypsum; Curing temperature; Strength; Expansion property; Mechanism analysis

刊期 : 2024年第7期

DOI : 10.19761/j.1000-4637.2024.07.083.06

文章编号 :

基金项目 : 四川省科技计划项目（2023YFSY0019）。

作者 : 王旭1，付建鹏1，金冰欣2，朱斌1，武双磊2，*，徐迅3

单位 : 1.桐庐宏基源混凝土有限公司，浙江杭州 311502；2.浙江大学材料科学与工程学院，浙江杭州 310027；3.西南科技大学土木工程与建筑学院，四川绵阳 621010

王旭1，付建鹏1，金冰欣2，朱斌1，武双磊2，*，徐迅3

王旭,付建鹏,金冰欣,等.养护温度与脱硫石膏掺量对RPC性能的影响[J].混凝土与水泥制品,2024(7):83-88.

WANG X,FU J P,JIN B X,et al.Effect of curing temperature and desulfurization gypsum content on performance of RPC[J].China Concrete and Cement Products,2024(7):83-88.





摘要

参数

结论

参考文献

引用本文

Abstract: Reactive powder concrete(RPC) was prepared by using ordinary Portland cement, desulfurization gypsum, slag, etc. The effects of curing temperature (20, 45, 70 ℃) and desulfurization gypsum content (2%~7%) on the strength and expansion rate of RPC were studied, and XRD and SEM analysis were conducted. The results show that when the curing temperature is 20 ℃, with the increase of desulfurization gypsum content, the 28 d flexural strength and compressive strength of the specimen first increase and then decrease. When the curing temperature is 45 ℃, with the increase of desulfurization gypsum content, the 28 d flexural strength of the specimen increases and the 28 d compressive strength first increases and then decreases. When the curing temperature is 70 ℃, the 28 d flexural strength and compressive strength of the specimen increase. When the content of desulfurization gypsum is the same, with the increase of curing temperature, the 28 d flexural strength and compressive strength of the specimen basically show an increasing trend. The higher the content of desulfurization gypsum, the greater the expansion rate of the specimen. The higher the curing temperature, the lower the expansion rate of the specimen when it tends to stabilize. Adding an appropriate content of gypsum to RPC, accompanied by an appropriate curing temperature can effectively promote the hydration process of cement and slag, generate ettringite, and improve the strength and expansion properties of RPC.

关键词:

the

and

strength

curing

temperature

gypsum

养护

扫二维码用手机看

[1] RICHARD P,CHEYREZY M.Composition of reactive powder concretes[J].Cement and Concrete Research,1995,25(7):1501-1511.
[2] ABID M,HOU X M,ZHENG W Z,et al.High temperature and residual properties of reactive powder concrete a review[J].Construction and Building Materials,2017,147:339-351.
[3] 毛振豪,张继承,李元齐,等.活性粉末混凝土高温后性能劣化及微观结构[J].建筑材料学报,2022,25(12):1225-1232.
[4] 王华,韩松,安明喆,等.活性粉末混凝土材料微观结构的研究现状[J].材料导报,2014,28(7):95-98,103.
[5] 朋改非,杨娟,石云兴.超高性能混凝土高温后残余力学性能试验研究[J].土木工程学报,2017,50(4):73-79.
[6] 林长宇,王启睿,杨立云,等.玄武岩纤维活性粉末混凝土在冲击载荷下的力学行为及本构关系[J].材料导报,2022,36(19):103-109.
[7] 赵秦仪,何兵,崔晓昱,等.长期高温水热条件下活性粉末混凝土的水化规律[J].硅酸盐学报,2020,48(5):665-674.
[8] 谢昊天,徐颖,杨荣周,等.聚丙烯纤维对RPC动态劈裂性能的影响[J].混凝土,2022(11):62-67.
[9] 孙磊,杜红秀.冷却方式对高温后RPC力学性能和超声波速的影响[J].混凝土,2022(10):34-37.
[10] 张荣华,徐迅,罗宏伟,等.活性粉末混凝土组成材料及制备方式研究综述[J].混凝土与水泥制品,2019(10):14-18.
[11] 陈宇,季军荣,周洲,等.超硫酸盐水泥早期强度影响因素及提高途径[J].硅酸盐通报,2021,40(5):1413-1419.
[12] 季军荣,武双磊,陈宇,等.利用电解锰渣制备活性粉末混凝土的研究[J].混凝土与水泥制品,2021(5):91-94,99.
[13] LI X Y,LI J,LU Z Y,et al.Preparation and properties of reactive powder concrete by using titanium slag aggregates[J].Construction and Building Materials,2020,234:117342.
[14] 林剑,吴岳峻,高帅,等.养护温度对活性粉末混凝土孔结构的影响研究[J].硅酸盐通报,2019,38(8):2600-2605.
[15] 杨胜江.不同养护制度对 RPC 混凝土力学性能的试验[J].低温建筑技术,2013,35(7):20-22.
[16] 于泳,鞠彦忠,王德弘.不同养护条件下钢纤维掺量对 RPC 强度的影响[J].混凝土与水泥制品,2015(4):42-44.
[17] 国家市场监督管理总局,国家标准化管理委员会.水泥胶砂强度检验方法(ISO法):GB/T 17671—2021[S].北京:中国标准出版社,2021.
[18] 中华人民共和国工业和信息化部.膨胀水泥膨胀率试验方法:JC/T 313—2009[S].北京:建材工业出版社,2009.
[19] 彭家惠,楼宗汉.钙矾石形成机理的研究[J].硅酸盐学报,2000,28(6):511-515.
[20] HARGIS C W,KIRCHHEIM A P,MONTEIRO P J M,et al.Early age hydration of calcium sulfoaluminate (synthetic ye’elimite,C4A3 S) in the presence of gypsum and varying amounts of calcium hydroxide[J].Cement and Concrete Research,2013,48:105-115.
[21] 张文生,张金山,叶家元,等.合成条件对钙矾石形貌的影响[J].硅酸盐学报,2017(5):631-638.
[22] ZHOU Q,GLASSER F P.Thermal stability and decomposition mechanisms of ettringite at <120 ℃[J].Cement and Concrete Research,2001,31(9):1333-1339.
[23] BARBARULO R,PEYCELON H,LECLERCQ S.Chemical equilibria between C-S-H and ettringite, at 20 and 85 ℃[J]. Cement and Concrete Research,2007,37(8):1176-1181.
[24] DIVET L,RANDRIAMBOLOLONA R,Delayed ettringite formation: The effect of temperature and basicity on the interaction of sulphate and C-S-H phase[J].Cement and Concrete Research,1998,28(3):357-363.

上一个

火灾高温环境下混凝土力学性能研究进展

下一个

低碳复合胶凝材料对水泥和混凝土性能的影响

头部文案

养护温度与脱硫石膏掺量对RPC性能的影响

相关文件