振动搅拌对复合胶凝材料混凝土性能的影响_《混凝土与水泥制品》杂志社

头部文案

发布时间：2020-01-06 00:00:00

全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊（光盘版）全文收录期刊

华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊



振动搅拌对复合胶凝材料混凝土性能的影响

Effect of vibratory mixing on properties of composite cementitious concrete

2024年第8期

复合胶凝材料；混凝土；振动搅拌；抗压强度；弹性模量

Composite cementitious material; Concrete; Vibratory mixing; Compressive strength; Elastic modulus

2024年第8期

10.19761/j.1000-4637.2024.08.016.06

国家自然科学基金项目（52272025）。

刘洋1，李鹏飞1，*，陈智勇1，赵春东2，朱云升2

1.四川省交通建设集团有限责任公司，四川成都610059；2.武汉理工大学交通与物流工程学院，湖北武汉430063

刘洋1，李鹏飞1，*，陈智勇1，赵春东2，朱云升2

刘洋,李鹏飞,陈智勇,等.振动搅拌对复合胶凝材料混凝土性能的影响[J].混凝土与水泥制品,2024(8):16-21.

LIU Y,LI P F,CHEN Z Y,et al.Effect of vibratory mixing on properties of composite cementitious concrete[J].China Concrete and Cement Products,2024(8):16-21.

浏览量:

1000

摘要：为研究振动搅拌对C50复合胶凝材料预制梁混凝土性能的影响，采用正交试验优化得到了混凝土最佳配合比，在最佳配合比下，对不同振动搅拌时间下混凝土的工作性、抗压强度和弹性模量进行了测试，并结合XRD、SEM分析了振动搅拌对混凝土力学性能的影响机理。结果表明：通过正交试验得到混凝土的最佳配合比为m水泥∶m矿粉∶m粉煤灰∶m硅灰∶m砂∶m5~10 mm碎石∶m10~20 mm碎石∶m水∶m减水剂=369∶27∶40.5∶13.5∶775∶214∶857∶144∶5.4；振动搅拌会使混凝土的流动性有所下降，当振动搅拌时间为90 s时，混凝土的出机坍落度和扩展度下降幅度最小；随着振动搅拌时间的增加，混凝土的抗压强度和弹性模量均呈先增加后降低的趋势，当振动搅拌时间为90 s时，混凝土的抗压强度和弹性模量达到最大；振动搅拌加快了水泥的水化速率，促进了C-S-H凝胶、Ca(OH)2晶体等水化产物的生成，水化产物能更充分地填充于混凝土界面过渡区的孔隙和裂缝处，增加了界面过渡区结构的致密性，从而提高了混凝土的强度。 Abstract：To study the effect of vibration mixing on the performance of C50 composite cementitious material precast beams concrete, orthogonal experiments were used to optimize the optimal concrete mix proportion. Under the optimal mix proportion, the workability, compressive strength, and elastic modulus of concrete under different vibration mixing times were tested, and the influence mechanism of vibration mixing on the mechanical properties of concrete was analyzed by combining XRD and SEM. The results show that the optimal mix proportion of concrete obtained through orthogonal experiments is mcement∶mmineral powder∶mfly ash∶msilica fume∶msand∶m5~10 mm crushed stone∶m10~20 mm crushed stone∶mwater∶mpolycarboxylate superplasticizer=369∶27∶40.5∶13.5∶775∶214∶857∶144∶5.4. Vibration mixing can cause a decrease in the flowability of concrete. When the vibration mixing time is 90 s, the minimum decrease in the slump and expansion of concrete is achieved. With the increase of vibration mixing time, the compressive strength and elastic modulus of concrete show a trend of first increasing and then decreasing. When the vibration mixing time is 90 s, the compressive strength and elastic modulus of concrete reach their maximum. Vibratory mixing accelerates the hydration rate of cement, and promotes the generation of hydration products such as C-S-H gel and Ca(OH)2 crystal. The hydration products can more fully fill the pores and cracks in the interface transition zone of concrete, increase the compactness of the interface transition zone structure, thus improving the strength of concrete.

英文名 : Effect of vibratory mixing on properties of composite cementitious concrete

刊期 : 2024年第8期

关键词 : 复合胶凝材料；混凝土；振动搅拌；抗压强度；弹性模量

Key words : Composite cementitious material; Concrete; Vibratory mixing; Compressive strength; Elastic modulus

刊期 : 2024年第8期

DOI : 10.19761/j.1000-4637.2024.08.016.06

文章编号 :

基金项目 : 国家自然科学基金项目（52272025）。

作者 : 刘洋1，李鹏飞1，*，陈智勇1，赵春东2，朱云升2

单位 : 1.四川省交通建设集团有限责任公司，四川成都610059；2.武汉理工大学交通与物流工程学院，湖北武汉430063

刘洋1，李鹏飞1，*，陈智勇1，赵春东2，朱云升2

刘洋,李鹏飞,陈智勇,等.振动搅拌对复合胶凝材料混凝土性能的影响[J].混凝土与水泥制品,2024(8):16-21.

LIU Y,LI P F,CHEN Z Y,et al.Effect of vibratory mixing on properties of composite cementitious concrete[J].China Concrete and Cement Products,2024(8):16-21.





摘要

参数

结论

参考文献

引用本文

摘要：为研究振动搅拌对C50复合胶凝材料预制梁混凝土性能的影响，采用正交试验优化得到了混凝土最佳配合比，在最佳配合比下，对不同振动搅拌时间下混凝土的工作性、抗压强度和弹性模量进行了测试，并结合XRD、SEM分析了振动搅拌对混凝土力学性能的影响机理。结果表明：通过正交试验得到混凝土的最佳配合比为m_水泥∶m_矿粉∶m_粉煤灰∶m_硅灰∶m_砂∶m_{5~10 mm碎石}∶m_{10~20 mm碎石}∶m_水∶m_减水剂=369∶27∶40.5∶13.5∶775∶214∶857∶144∶5.4；振动搅拌会使混凝土的流动性有所下降，当振动搅拌时间为90 s时，混凝土的出机坍落度和扩展度下降幅度最小；随着振动搅拌时间的增加，混凝土的抗压强度和弹性模量均呈先增加后降低的趋势，当振动搅拌时间为90 s时，混凝土的抗压强度和弹性模量达到最大；振动搅拌加快了水泥的水化速率，促进了C-S-H凝胶、Ca(OH)₂晶体等水化产物的生成，水化产物能更充分地填充于混凝土界面过渡区的孔隙和裂缝处，增加了界面过渡区结构的致密性，从而提高了混凝土的强度。

Abstract：To study the effect of vibration mixing on the performance of C50 composite cementitious material precast beams concrete, orthogonal experiments were used to optimize the optimal concrete mix proportion. Under the optimal mix proportion, the workability, compressive strength, and elastic modulus of concrete under different vibration mixing times were tested, and the influence mechanism of vibration mixing on the mechanical properties of concrete was analyzed by combining XRD and SEM. The results show that the optimal mix proportion of concrete obtained through orthogonal experiments is m_cement∶m_{mineral powder}∶m_{fly ash}∶m_{silica fume}∶m_sand∶m_{5~10 mm crushed stone}∶m_{10~20 mm crushed stone}∶m_{water∶mpolycarboxylate superplasticizer}=369∶27∶40.5∶13.5∶775∶214∶857∶144∶5.4. Vibration mixing can cause a decrease in the flowability of concrete. When the vibration mixing time is 90 s, the minimum decrease in the slump and expansion of concrete is achieved. With the increase of vibration mixing time, the compressive strength and elastic modulus of concrete show a trend of first increasing and then decreasing. When the vibration mixing time is 90 s, the compressive strength and elastic modulus of concrete reach their maximum. Vibratory mixing accelerates the hydration rate of cement, and promotes the generation of hydration products such as C-S-H gel and Ca(OH)₂ crystal. The hydration products can more fully fill the pores and cracks in the interface transition zone of concrete, increase the compactness of the interface transition zone structure, thus improving the strength of concrete.

扫二维码用手机看

[1] 刘沐宇,曾宏伟,邓晓光,等.大跨径PC小箱梁桥合理施工顺序及抗裂措施[J].武汉理工大学学报(交通科学与工程版), 2021,45(6):1123-1127.
[2] 卢玲霞.矿物掺合料对高强机制砂混凝土早期收缩开裂性能的影响[J].粉煤灰综合利用,2024,38(2):17-21,30.
[3] 高伟,马志才,苏磊,等.大掺量矿物掺合料混凝土耐久性研究[J].济源职业技术学院学报,2023,22(4):54-58.
[4] 秦华东,孟伟峰,来立志.预制梁用C50缓凝早强大流态混凝土的研制与应用[J].混凝土,2006(4):65-69.
[5] 刘辉,王镜超.早强剂复掺对装配式构件混凝土性能的影响[J].混凝土与水泥制品,2023(12):50-53.
[6] ALANAZI H.Equivalent CO2 emission and cost analysis of green self-compacting rubberized concrete[J].Sustainability,2021,137(14):137-145.
[7] 黄天勇,陈旭峰,李胜,等.振动搅拌对混凝土性能的影响与机理分析[J].混凝土世界,2018,113(11):56-60.
[8] 姚运仕,刘欢建,任峰,等.高性能混凝土振动搅拌试验研究[J].硅酸盐通报,2020,39(3):730-733.
[9] 王开凤,赵春东,刘洋,等.振动搅拌对复掺预制梁混凝土性能的影响研究[J/OL].武汉理工大学学报(交通科学与工程版),2023,47(4):1-12[2024-06-11].http://kns.cnki.net/kcms/detail/42.
1824.U.20230704.1335.050.html.
[10] 张颜科,路珏,杨迎,等.振动搅拌对普通混凝土和超高性能混凝土性能的影响[J].混凝土与水泥制品,2023(11):16-21.
[11] 徐志华,邓俊双,刘战鳌,等.机制砂中细粉MB值对混凝土性能影响规律的研究[J].武汉理工大学学报(交通科学与工程版),2021,45(6):1151-1157.
[12] 连雅萍.机制砂亚甲蓝特性及其对混凝土性能的影响研究[J].广东建材,2024,40(4):23-26.
[13] 潘鑫,艾金华,何倍,等.关于亚甲蓝法表征机制砂中黏土含量的思考[J].混凝土,2022(7):67-73.
[14] 冷发光,路珏,王晶,等.振动搅拌技术在混凝土中的应用进展[J].混凝土世界,2023(9):78-81.
[15] 何志勇,阳洁颖,邹丽梅.双卧轴振动搅拌对超高性能混凝土性能的影响研究[J].长沙理工大学学报(自然科学版),2023,20(5):154-162.
[16] 王安怀.振动搅拌混凝土技术在工程中的应用研究[J].公路,2023,68(9):364-367.
[17] ZHENG Y,WU X,HE G,et al.Mechanical properties of steel fiber-reinforced concrete by vibratory mixing technology[J].Advances in Civil Engineering,2018(5):1-11.
[18] GZDE N S.Compressive strength and sulfate resistance of limestone and/or silica fume mortars[J].Construction and Building Materials,2012,26(1):613-618.
[19] ZHANG Y K,CHEN E Y,GUO Z L.Experimental study on the combined aggregate concrete strength[J].Advanced Materials Research,2012,450(1):413-420.
[20] 赵悟,杨泽文,宋儒霖,等.振动搅拌对机制砂混凝土性能影响研究[J].新型建筑材料,2021,48(7):71-74.

上一个

超高性能混凝土与普通混凝土结合面抗腐蚀及力学性能研究

下一个

黏度改性材料对泵送混凝土性能的影响

头部文案

振动搅拌对复合胶凝材料混凝土性能的影响

相关文件