混凝土不均匀性的表征及其对硬化性能的影响

头部文案

发布时间：2020-01-06 00:00:00

全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊（光盘版）全文收录期刊

华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊



混凝土不均匀性的表征及其对硬化性能的影响

Characterization of concrete inhomogeneity and its influence on the hardened concrete properties

2024年第9期

混凝土；不均匀性；骨料离析；渗透性能；坍落度

Concrete; Inhomogeneity; Aggregate segregation; Permeability; Slump

2024年第9期

10.19761/j.1000-4637.2024.09.007.06

国家重点研发计划项目（2021YFB3802000、2021YFB3802004）。

刘强1，庞超明2，*，罗时勇2，陈嘉俊2，张萍2

1.中国核工业华兴建设有限公司，江苏南京 210019；2.东南大学材料科学与工程学院，江苏省土木工程材料重点实验室，江苏南京 211189

刘强1，庞超明2，*，罗时勇2，陈嘉俊2，张萍2

刘强,庞超明,罗时勇,等.混凝土不均匀性的表征及其对硬化性能的影响[J].混凝土与水泥制品,2024(9):7-12.

LIU Q,PANG C M,LUO S Y,et al.Characterization of concrete inhomogeneity and its influence on the hardened concrete properties[J].China Concrete and Cement Products ,2024(9):7-12.

浏览量:

1000

摘要：为了研究新拌混凝土不均匀性对硬化性能的影响，制备了坍落度在130~260 mm的大流动度C50混凝土，通过砂率、矿物掺合料掺量和减水剂掺量调节混凝土的流动性，取不同部位（中心、边缘）混凝土测试工作性、力学性能、渗透性能等。结果表明：当中心、边缘混凝土骨料离析率组间变异系数不超过5%时，对混凝土的力学性能无明显影响；随着骨料离析率组间变异系数的增加，混凝土力学性能降低；同组间对比时，各组边缘混凝土的氯离子扩散系数、气体渗透系数均高于中心混凝土，中心混凝土的孔隙率较低，有害级孔和多害级孔占比低于边缘混凝土，中心、边缘混凝土的骨料离析率和水胶比组间变异系数较大的组别，孔径分布及孔隙率的差值也较大，氯离子扩散系数和气体渗透系数的差值也较大；总体上，新拌混凝土越均匀，硬化后的综合性能越好。 Abstract: In order to study the effect of inhomogeneity of fresh concrete on its hardened performance, high fluidity C50 concrete with a slump of 130~260 mm was prepared. The fluidity of the concrete was adjusted by sand ratio, mineral admixture content, and polycarboxylate superplasticizer content. Different parts(center, edge) of the concrete were tested for workability, mechanical properties, permeability, etc. The results show that when the coefficient of variation between the segregation rate groups of the center and edge concrete aggregates does not exceed 5%, it has no significant effect on the mechanical properties of concrete. As the coefficient of variation between the segregation rate groups increases, the mechanical properties of concrete decrease. When comparing within the same group, the chloride ion diffusion coefficient and gas permeability coefficient of the edge concrete in each group are higher than those of the center concrete. The porosity of the center concrete is lower, and the proportion of harmful and multi harmful pores is lower than those of the edge concrete. The groups with larger inter group variation coefficients of aggregate segregation rate and water binder ratio in the center and edge concrete also have larger differences in pore size distribution and porosity, and larger differences in chloride ion diffusion coefficient and gas permeability coefficient. Overall, the more uniform the freshly mixed concrete, the better its comprehensive performance after hardening.

英文名 : Characterization of concrete inhomogeneity and its influence on the hardened concrete properties

刊期 : 2024年第9期

关键词 : 混凝土；不均匀性；骨料离析；渗透性能；坍落度

Key words : Concrete; Inhomogeneity; Aggregate segregation; Permeability; Slump

刊期 : 2024年第9期

DOI : 10.19761/j.1000-4637.2024.09.007.06

文章编号 :

基金项目 : 国家重点研发计划项目（2021YFB3802000、2021YFB3802004）。

作者 : 刘强1，庞超明2，*，罗时勇2，陈嘉俊2，张萍2

单位 : 1.中国核工业华兴建设有限公司，江苏南京 210019；2.东南大学材料科学与工程学院，江苏省土木工程材料重点实验室，江苏南京 211189

刘强1，庞超明2，*，罗时勇2，陈嘉俊2，张萍2

刘强,庞超明,罗时勇,等.混凝土不均匀性的表征及其对硬化性能的影响[J].混凝土与水泥制品,2024(9):7-12.

LIU Q,PANG C M,LUO S Y,et al.Characterization of concrete inhomogeneity and its influence on the hardened concrete properties[J].China Concrete and Cement Products ,2024(9):7-12.





摘要

参数

结论

参考文献

引用本文

Abstract: In order to study the effect of inhomogeneity of fresh concrete on its hardened performance, high fluidity C50 concrete with a slump of 130~260 mm was prepared. The fluidity of the concrete was adjusted by sand ratio, mineral admixture content, and polycarboxylate superplasticizer content. Different parts(center, edge) of the concrete were tested for workability, mechanical properties, permeability, etc. The results show that when the coefficient of variation between the segregation rate groups of the center and edge concrete aggregates does not exceed 5%, it has no significant effect on the mechanical properties of concrete. As the coefficient of variation between the segregation rate groups increases, the mechanical properties of concrete decrease. When comparing within the same group, the chloride ion diffusion coefficient and gas permeability coefficient of the edge concrete in each group are higher than those of the center concrete. The porosity of the center concrete is lower, and the proportion of harmful and multi harmful pores is lower than those of the edge concrete. The groups with larger inter group variation coefficients of aggregate segregation rate and water binder ratio in the center and edge concrete also have larger differences in pore size distribution and porosity, and larger differences in chloride ion diffusion coefficient and gas permeability coefficient. Overall, the more uniform the freshly mixed concrete, the better its comprehensive performance after hardening.

扫二维码用手机看

[1] 党玉栋,马晓杰,董晨辉,等.混凝土材料物理性能的空间非均匀性表现[J].建筑材料学报,2019,22(2):260-265.
[2] 祝昌暾,周志斌,王章夫.混凝土工作性对灌注桩质量的影响[J].混凝土,2007(1):74-75,78.
[3] 戴镇潮.混凝土强度的标准差和变异系数[J].混凝土与水泥制品,1999(6):7-10.
[4] 韩素芳.混凝土强度及其匀质性调查结果分析[J].混凝土及加筋混凝土,1987(5):9-14.
[5] 庞超明,秦鸿根,曹鹏飞,等.影响自密实混凝土性能的因素探讨[C]//中国硅酸盐学会.第二届全国商品混凝土信息技术交流大会.新乡:建筑材料工业技术情报研究所,2005:44-49.
[6] UNGER J F,ECKARDT S.Multiscale modeling of concrete[J].Archives of computational methods in engineering,2011,18(3):341-393.
[7] WAWRZENCZYK J,MOLENDOWSKA A,KLAK A.Quantitative assessment of aggregate segregation of hardened self compacted concrete based on 2D image analysis[C]//Vilnius Gediminas Technical University.The 13th International Scientific Conference "Modern Building Materials,Structures and Techniques".Vilnius:Vilnius Gediminas Technical University,2019:14-15.
[8] 任炳昱,叶钲军,王栋,等.基于改进MaskR-CNN的硬化混凝土离析程度评价[J].水力发电学报,2022,41(5):93-102.
[9] 高海鹏,田波,郝冠军,等.新拌水泥混凝土均匀性评价方法[J].公路交通科技,2014,31(12):25-30.
[10] 余志龙,田建涛,孔鲜宁.混凝土离析评定方法的研究[J].山东交通学院学报,2013,21(4):47-50.
[11] 高晓刚,王恩涛.超声波声时判断混凝土的密实性与均匀性[J].北方交通,2013(增刊2):73-75.
[12] 成振林,王小东.粗骨料对混凝土性能的影响[J].混凝土与水泥制品,2012(6):22-24.
[13] 李良茂.针片状骨料对混凝土性能的影响[J].混凝土与水泥制品,1990(1):2-5.
[14] 赖泽成.复合改性再生粗骨料对混凝土性能的影响[J].混凝土与水泥制品,2023(10):90-94.
[15] 张成银,郑磊,刘长顺,等.粗骨料级配对混凝土早期收缩性能的影响[J].混凝土与水泥制品,2022(11):27-29,34.
[16] KOEHLER E P,FOWLER D W.Summary of concrete workability test methods[J].Concrete Journal,2003(1):003110.
[17] 罗骐先.用纵波超声换能器测量砼表面波速和动弹性模量[J].水利水运科学研究,1996(3):264-270.
[18] 庞超明,罗时勇,秦鸿根,等.混凝土气体渗透性试验方法[J].东南大学学报(自然科学版),2014,44(6):1235-1239.
[19] 蔡基伟.自密实混凝土中砂浆与粗骨料的离析趋势[C]//中国硅酸盐学会混凝土与水泥制品分会.第十三届高性能混凝土学术研讨会论文集.唐山:华北理工大学,2019:6.
[20] WANG G M,KONG Y,SUN T,et al.Effect of water-binder ratio and fly ash on the homogeneity of concrete[J].Construction and Building Materials,2013,38:1129-1134.

上一个

混凝土配合比设计中的骨料问题研究

下一个

材料组份对高强环氧灌浆料性能影响研究

头部文案

混凝土不均匀性的表征及其对硬化性能的影响

相关文件