苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
废玻璃掺合料对混凝土力学性能的影响
Effects of Waste Glass Powder Admixture on Mechanical Properties of Concrete
2019年第6期
废玻璃粉掺合料;混凝土;力学性能
Waste glass powder admixture; Concrete; Mechanical property
2019年第6期
10.19761/j.1000-4637.2019.06.094.04
河南省科技攻关项目(162102310409);河南省高等学校重点科研项目(17A560020)资助
静 行,刘雷鸣,赵 毅,王爱勤
1.河南工业大学土木建筑学院,郑州 450001;2.中原工学院建筑工程学院,郑州 451191; 3.苏州混凝土水泥制品研究院有限公司,215004

静 行,刘雷鸣,赵 毅,王爱勤

静行,刘雷鸣,赵毅,等.废玻璃掺合料对混凝土力学性能的影响[J].混凝土与水泥制品,2019(6):94-97.

JING X,LIU L M,ZHAO Y,et al.Effects of Waste Glass Powder Admixture on Mechanical Properties of Concrete[J].China Concrete and Cement Products,2019(6):94-97.

浏览量:
1000
摘 要:为了研究废玻璃掺合料对混凝土各项力学性能的影响,对不同玻璃粉粒径(150~830 μm、75~150 μm、25~75 μm)和不同体积掺量(5%、10%、15%、20%)的废玻璃掺合料混凝土进行了抗压强度、劈裂抗拉强度和静弹性模量性能测试,分析了废玻璃粉粒径和体积掺量对混凝土力学性能的影响,同时研究了废玻璃粉掺合料混凝土的拉压比和弹强比。结果表明:废玻璃粉掺合料对混凝土力学性能影响较大,当玻璃粉掺量≥10%时,混凝土的抗压强度均有不同程度的提高,玻璃粉粒径越细,混凝土的抗压强度越高。随着废玻璃粉掺量增加,混凝土劈裂抗拉强度持续降低,拉压比减小。混凝土弹性模量随着玻璃粉的掺入均出现不同程度的增大,且玻璃粉粒径越小,弹性模量越大,弹强比随玻璃粉掺量先增大后减小。 Abstract: In order to study the influence of waste glass admixture on the mechanical properties of concrete, the compressive strength, splitting tensile strength and static elastic modulus of waste glass admixture concrete with different glass powder size (150~830 μm、75~150 μm、150~830 μm) and different volume content (5%, 10%, 15%, 20%) were tested. The influence of particle size and volume content of waste glass powder on the mechanical properties of concrete was analyzed, and the tension-compression ratio and elastic strength ratio of concrete were also studied. The results show that the waste glass admixture has great influence on the mechanical properties of concrete, when the content of glass powder is more than 10%, the compressive strength of concrete increases. And the finer the size of glass powder, the higher the compressive strength of concrete. With the increase of waste glass powder content, the splitting tensile strength and the tension-compression ratio of concrete decrease continuously. The elastic modulus of concrete increases in varying degrees with the addition of glass powder, and the smaller the particle size of glass powder, the larger the elastic modulus of the concrete. The elastic strength ratio first increases and then decreases with the addition of glass powder.
英文名 : Effects of Waste Glass Powder Admixture on Mechanical Properties of Concrete
刊期 : 2019年第6期
关键词 : 废玻璃粉掺合料;混凝土;力学性能
Key words : Waste glass powder admixture; Concrete; Mechanical property
刊期 : 2019年第6期
DOI : 10.19761/j.1000-4637.2019.06.094.04
文章编号 :
基金项目 : 河南省科技攻关项目(162102310409);河南省高等学校重点科研项目(17A560020)资助
作者 : 静 行,刘雷鸣,赵 毅,王爱勤
单位 : 1.河南工业大学土木建筑学院,郑州 450001;2.中原工学院建筑工程学院,郑州 451191; 3.苏州混凝土水泥制品研究院有限公司,215004

静 行,刘雷鸣,赵 毅,王爱勤

静行,刘雷鸣,赵毅,等.废玻璃掺合料对混凝土力学性能的影响[J].混凝土与水泥制品,2019(6):94-97.

JING X,LIU L M,ZHAO Y,et al.Effects of Waste Glass Powder Admixture on Mechanical Properties of Concrete[J].China Concrete and Cement Products,2019(6):94-97.

摘要
参数
结论
参考文献
引用本文

摘   要:为了研究废玻璃掺合料对混凝土各项力学性能的影响,对不同玻璃粉粒径(150~830 μm、75~150 μm、25~75 μm)和不同体积掺量(5%、10%、15%、20%)的废玻璃掺合料混凝土进行了抗压强度、劈裂抗拉强度和静弹性模量性能测试,分析了废玻璃粉粒径和体积掺量对混凝土力学性能的影响,同时研究了废玻璃粉掺合料混凝土的拉压比和弹强比。结果表明:废玻璃粉掺合料对混凝土力学性能影响较大,当玻璃粉掺量≥10%时,混凝土的抗压强度均有不同程度的提高,玻璃粉粒径越细,混凝土的抗压强度越高。随着废玻璃粉掺量增加,混凝土劈裂抗拉强度持续降低,拉压比减小。混凝土弹性模量随着玻璃粉的掺入均出现不同程度的增大,且玻璃粉粒径越小,弹性模量越大,弹强比随玻璃粉掺量先增大后减小。
Abstract: In order to study the influence of waste glass admixture on the mechanical properties of concrete, the compressive strength, splitting tensile strength and static elastic modulus of waste glass admixture concrete with different glass powder size (150~830 μm、75~150 μm、150~830 μm) and different volume content (5%, 10%, 15%, 20%) were tested. The influence of particle size and volume content of waste glass powder on the mechanical properties of concrete was analyzed, and the tension-compression ratio and elastic strength ratio of concrete were also studied. The results show that the waste glass admixture has great influence on the mechanical properties of concrete, when the content of glass powder is more than 10%, the compressive strength of concrete increases. And the finer the size of glass powder, the higher the compressive strength of concrete. With the increase of waste glass powder content, the splitting tensile strength and the tension-compression ratio of concrete decrease continuously. The elastic modulus of concrete increases in varying degrees with the addition of glass powder, and the smaller the particle size of glass powder, the larger the elastic modulus of the concrete. The elastic strength ratio first increases and then decreases with the addition of glass powder.

关键词:
废玻璃粉掺合料;混凝土;力学性能
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)废玻璃粉掺合料对混凝土立方体抗压强度影响较大,当玻璃粉掺量≥10%时,混凝土的抗压强度较基准组均有不同程度的提高,玻璃粉掺合料体积掺量为15%时,混凝土抗压强度增长率最大,且在相同玻璃粉掺量的情况下,玻璃粉粒径越细,混凝土的抗压强度越高。
(2)随着废玻璃粉掺量的增加,混凝土劈裂抗拉强度呈持续下降趋势,其中,掺入较大粒径(150~830 μm)的废玻璃粉混凝土劈裂抗拉强度降低最显著;掺入75~150 μm和25~75 μm玻璃粉的混凝土劈裂抗拉强度变化趋势较为接近,当玻璃粉掺量≤15%时,劈裂抗拉强度降低程度较小,而当掺量达到20%时,其抗拉强度急剧下降。
(3)混凝土拉压比随着废玻璃粉掺量的增加而逐渐减小。其中,掺加150~830 μm玻璃粉混凝土的拉压比降低最显著,其次为掺加25~75 μm玻璃粉的混凝土,75~150 μm玻璃粉混凝土的拉压比降低程度最小。
(4)混凝土弹性模量随着玻璃粉掺量的增加均出现不同程度的增大,相同掺量时,玻璃粉粒径越小,混凝土弹性模量越大。各组混凝土弹强比随着废玻璃粉掺量的增加呈现先增大后减小的趋势,除G-C-15外,其他各组混凝土弹强比相对于基准组均有不同程度增加。
 

[1] 中华人民共和国建设部.GB/T 50081—2002 普通混凝土拌合物性能试验方法标准[S].北京:中国建筑工业出版社, 2016.
[2] 邓攀,陆启宏,柯国军,等.不同粒径及掺量废玻璃粉对混凝土抗碳化性能的影响[J].混凝土与水泥制品,2018(4):95-98.
[3] 赵祖芳,李碧雄,朱亚阁.单掺废玻璃再生混凝土的最优取代率试验研究[J].工程科学与技术, 2017(S2):102-109.
[4] 曾超,甘元初,柯国军,等.废玻璃粉混凝土力学性能试验研究[J].硅酸盐通报,2014,33(2):377-381.
[5] 李丽华,任增乐,杨俊超,等. 废弃玻璃粉在混凝土中的应用机理及ASR风险[J].长江科学院院报,2016,33(2):94-99.
[6] 刘光焰,金大智,戴昌强,等.掺玻璃粉混凝土的力学性能[J]. 河南科技大学学报:自然科学版,2018(1):59-62.
[7] 王海娟,张义顺,赵继芬,等.利用废旧玻璃粉细掺料制备混凝土实验研究[J].河南理工大学学报:自然科学版,2012,31(5):608-612.
[8] 罗锟,梁炯丰,邓宇.再生玻璃粗骨料混凝土基本力学性能研究[J].科学技术与工程,2013,25(13):7585-7587.
[9] 严建华,柏晓强,崔素萍,等.废弃玻璃在混凝土中的应用研究进展[J].硅酸盐通报,2017,36(4):1228-1233.

静行,刘雷鸣,赵毅,.废玻璃掺合料对混凝土力学性能的影响[J].混凝土与水泥制品,2019(6):94-97.

JING X,LIU L M,ZHAO Y,et al.Effects of Waste Glass Powder Admixture on Mechanical Properties of Concrete[J].China Concrete and Cement Products,2019(6):94-97.

 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州