苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
基于DIC方法的预应力梁桥疲劳试验研究
Fatigue Experimental Research on Prestressed Girder Bridge Based on DIC Method
2017年第6期
裂缝扩展;数字图像相关;预应力混凝土梁桥;疲劳;挠度
Crack propagation; DIC method; Prestressed girder bridge; Fatigue; Deflection
2017年第6期
1000-4637(2017)06-42-04
国家自然科学基金项目(51378169)
赵亚军1,2 ,窦远明1
.河北工业大学土木工程学院,天津300401;2.河北工程大学土木工程学院,邯郸056038

赵亚军1,2 ,窦远明1

赵亚军,窦远明.基于DIC方法的预应力梁桥疲劳试验研究[J].混凝土与水泥制品,2017(6):42-45.

ZHAO Y J, DOU Y M.Fatigue Experimental Research on Prestressed Girder Bridge Based on DIC Method[J].China Concrete and Cement Products,2017(6):42-45.

浏览量:
1000
摘 要:对16m长全尺寸预应力混凝土梁桥原型进行三点弯曲疲劳试验,利用数字图像相关(Digital Image Correlation,DIC)方法获得集中力作用点附近区域的变形场及应变场信息。经过200万次疲劳循环作用,研究了梁体侧面裂缝的萌生、成核、扩展机理。试验结果表明,主裂缝由次裂缝诱发萌生,主裂缝随疲劳循环次数而扩展,50万次之前的扩展速率明显大于50万次以后的扩展速率。随着主裂缝的扩展,次裂缝略有闭合。疲劳荷载不超过设计荷载时,钢绞线具有较好的拉结作用,预应力混凝土梁裂缝开展缓慢稳定,有明显的刚度退化。与传统电测法相比,DIC方法可准确观测全场裂缝扩展过程,可应用于对预应力桥梁的分析研究。 Abstract: Three point bending fatigue test was carried on full-size prototype of a 16m length prestressed concrete girder bridges. The strain field and strain field information near the loading point were obtained using Digital Image Correlation (DIC) method. After 2 million times of fatigue cycle, the crack initiation, nucleation and growth mechanism of the beam were studied. The experiment results show that, the main crack initiation induced by crack, the main crack extension according to the fatigue cycles, the extension rate before 500000 cycles significantly greater than that after 500000 cycles. Crack closure slightly with the expansion of the main crack. The fatigue load is less than the design load, steel strand has good tie effect, crack developing slowly and steady, the stiffness degradate obviously. Compared with the traditional measurement method, DIC method can observe the crack extension process accurately, which can be applied to analysis and research of prestressed concrete bridges.
英文名 : Fatigue Experimental Research on Prestressed Girder Bridge Based on DIC Method
刊期 : 2017年第6期
关键词 : 裂缝扩展;数字图像相关;预应力混凝土梁桥;疲劳;挠度
Key words : Crack propagation; DIC method; Prestressed girder bridge; Fatigue; Deflection
刊期 : 2017年第6期
DOI :
文章编号 : 1000-4637(2017)06-42-04
基金项目 : 国家自然科学基金项目(51378169)
作者 : 赵亚军1,2 ,窦远明1
单位 : .河北工业大学土木工程学院,天津300401;2.河北工程大学土木工程学院,邯郸056038

赵亚军1,2 ,窦远明1

赵亚军,窦远明.基于DIC方法的预应力梁桥疲劳试验研究[J].混凝土与水泥制品,2017(6):42-45.

ZHAO Y J, DOU Y M.Fatigue Experimental Research on Prestressed Girder Bridge Based on DIC Method[J].China Concrete and Cement Products,2017(6):42-45.

摘要
参数
结论
参考文献
引用本文

摘   要:对16m长全尺寸预应力混凝土梁桥原型进行三点弯曲疲劳试验,利用数字图像相关(Digital Image Correlation,DIC)方法获得集中力作用点附近区域的变形场及应变场信息。经过200万次疲劳循环作用,研究了梁体侧面裂缝的萌生、成核、扩展机理。试验结果表明,主裂缝由次裂缝诱发萌生,主裂缝随疲劳循环次数而扩展,50万次之前的扩展速率明显大于50万次以后的扩展速率。随着主裂缝的扩展,次裂缝略有闭合。疲劳荷载不超过设计荷载时,钢绞线具有较好的拉结作用,预应力混凝土梁裂缝开展缓慢稳定,有明显的刚度退化。与传统电测法相比,DIC方法可准确观测全场裂缝扩展过程,可应用于对预应力桥梁的分析研究。

Abstract: Three point bending fatigue test was carried on full-size prototype of a 16m length prestressed concrete girder bridges. The strain field and strain field information near the loading point were obtained using Digital Image Correlation (DIC) method. After 2 million times of fatigue cycle, the crack initiation, nucleation and growth mechanism of the beam were studied. The experiment results show that, the main crack initiation induced by crack, the main crack extension according to the fatigue cycles, the extension rate before 500000 cycles significantly greater than that after 500000 cycles. Crack closure slightly with the expansion of the main crack. The fatigue load is less than the design load, steel strand has good tie effect, crack developing slowly and steady, the stiffness degradate obviously. Compared with the traditional measurement method, DIC method can observe the crack extension process accurately, which can be applied to analysis and research of prestressed concrete bridges.

关键词:
裂缝扩展;数字图像相关;预应力混凝土梁桥;疲劳;挠度
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)主裂缝是由次裂缝引发微裂缝,经疲劳载荷作用萌生成核,随着疲劳损伤累积,主裂缝从成核位置向下迅速扩展,直至贯通底部,荷载循环次数仅为40万次。
(2)主裂缝贯通底部后向上扩展不明显,但疲劳损伤使得预应力混凝土梁刚度降低,主裂缝宽度及梁挠度逐渐增大,次裂缝停止扩展,甚至略有闭合趋势。
(3)经过200万次疲劳荷载作用后,预应力钢绞线仍具有较高的预应力,但整根梁已出现明显的刚度退化。
(4)数字图像相关方法可应用于大型构件、结构的表面裂缝观察、追踪扩展情况,为结构变形提供相关计算依据。
[1] 马建,孙守增,杨琦,等.中国桥梁工程学术研究综述·2014[J].中国公路学报,2014,27(5):1-96.
[2] 楼庄鸿.论预应力混凝土梁桥的裂缝[J].公路交通科技,2000,17(6):49-52.
[3] 曾丁,王国亮,谢峻,等.预应力混凝土梁疲劳预应力损失探索性试验[J].公路交通科技,2013,30(6):49-55.
[4] 李进洲,余志武,宋力.疲劳重复荷载下预应力混凝土梁的刚度退化规律[J].公路交通科技,2013,30(8):62-69.
[5] 金观昌,孟利波,陈俊达,等.数字散斑相关技术进展及应用[J].试验力学,2006,21(6):689-702.
[6] Bora Gencturk,Kazi Hossain,Aadit Kapadia,et al.Use of digital image correlation technique in full-scale testing of prestressed concrete structures[J]. Measurement, 2014,47:505-515.
[7] Mohammed Mahal,Thomas Blanksv?覿rd , Bj?觟rn T?覿ljsten, et al. Using digital image correlation to evaluate fatigue behavior of strengthened reinforced concrete beams[J].Engineering Structures,2015,105(15):277-288.
[8] Peters W H,Ranson W F. Digital Image Techniques in Experimental Mechanics[J].Optical Engineering,1982,21(3):427-431.
[9] YAMAGUCHI I.A Laser-Speckle Strain gage[J].Journal of Physis E:Scientific Instruments,1981,14:1270-1273.
[10] 赵川,窦远明,孙吉书.特殊情况下高速公路桥梁车辆荷载探讨[J].重庆交通大学学报,2015,34(2):15-19.

赵亚军,窦远明.基于DIC方法的预应力梁桥疲劳试验研究[J].混凝土与水泥制品,2017(6):42-45.

ZHAO Y J, DOU Y M.Fatigue Experimental Research on Prestressed Girder Bridge Based on DIC Method[J].China Concrete and Cement Products,2017(6):42-45.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州