苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
煅烧水滑石对海水海砂混凝土性能影响的研究
Influence Research of Calcined Layerd Double Hydrixide on Performance of Seawater-seasand Concrete
2017年第10期
海水海砂混凝土;极化电位;护筋性;掺合料;煅烧水滑石;强度
Seawater-seasand concrete; Polarization potential; Rebar-protecting property; Admixture; Calcined layerd double hydrixide;Streng
2017年第10期
1000-4637(2017)10-01-05
乔 治1,张 磊1,2,王志杰3,杨久俊1,2
1.天津城建大学材料科学与工程学院,300384;2.天津市建筑垃圾与燃煤废弃物 利用技术工程中心,300384;3.河南建筑材料研究设计院有限责任公司,郑州 450002

乔 治1,张 磊1,2,王志杰3,杨久俊1,2

乔治,张磊,王志杰,等.煅烧水滑石对海水海砂混凝土性能影响的研究[J].混凝土与水泥制品,2017(10):1-5.

QIAO Z, ZHANG L, WANG Z J,et al.Influence Research of Calcined Layerd Double Hydrixide on Performance of Seawater-seasand Concrete[J].China Concrete and Cement Products,2017(10):1-5.

浏览量:
1000
摘  要:通过分析阳极极化电位-时间曲线、Cl-固结能力、水泥净浆的pH值来研究煅烧水滑石(CLDH)对海水海砂混凝土护筋性的影响,并与矿渣和粉煤灰进行比较。此外,还研究了煅烧水滑石对海水海砂混凝土力学性能的影响。结果表明,煅烧水滑石、矿渣、粉煤灰单掺掺量分别为6%、50%、20%时,海水海砂混凝土护筋性较好,Cl-固结能力较好。护筋性与Cl-固结能力呈现出良好的相关性。矿物掺合料掺量越高,水泥净浆pH越低;煅烧水滑石掺量越高,水泥净浆pH越高。改善海水海砂混凝土护筋性的能力依次为:煅烧水滑石>矿渣>粉煤灰,矿物掺合料对护筋性的影响十分有限。煅烧水滑石降低海水海砂混凝土的3d强度,但可增加海水海砂混凝土28d强度。Abstract:TheeffectofCLDH(CalcinedLayerdDoubleHydrixide)onrebar-protectingpropertiesofseawater-seasandconcretewasstudiedbyanalyzingcurveofrebarpolarizationandtime,chlorideioncombination,pHvalueofcementpasteandcomparedwiththeeffectofslagandflyash.Inaddition,themechanicalpropertiesofseawater-seasandconcretearealsostudied.TheresultsshowthatwhentheCLDHcontentis6%,theslagcontentis50%andtheflyashcontentis20%,rebar-protectingpropertiesofseawater-seasandconcreteisrelativelysuperior,chlorideioncombinationisrelativelysuperior.Thereisthegoodcorrelationbetweenchlorideioncombinationandrebar-protectingproperties.Themoreadmixturecontent,thelowerpHvalueofcementpaste;ThemoreCLDHcontent,thehigherpHvalueofcementpaste.Theabilityofimprovementofrebar-protectingpropertiesisinsequenceofCLDH>slag>flyash,theadmixturehaslimitedimprovementontherebar-protectingproperties.CLDHcandecreasethe3dstrengthofseawater-seasandconcrete,butincreaseits28dstrength.
英文名 : Influence Research of Calcined Layerd Double Hydrixide on Performance of Seawater-seasand Concrete
刊期 : 2017年第10期
关键词 : 海水海砂混凝土;极化电位;护筋性;掺合料;煅烧水滑石;强度
Key words : Seawater-seasand concrete; Polarization potential; Rebar-protecting property; Admixture; Calcined layerd double hydrixide;Streng
刊期 : 2017年第10期
DOI :
文章编号 : 1000-4637(2017)10-01-05
基金项目 :
作者 : 乔 治1,张 磊1,2,王志杰3,杨久俊1,2
单位 : 1.天津城建大学材料科学与工程学院,300384;2.天津市建筑垃圾与燃煤废弃物 利用技术工程中心,300384;3.河南建筑材料研究设计院有限责任公司,郑州 450002

乔 治1,张 磊1,2,王志杰3,杨久俊1,2

乔治,张磊,王志杰,等.煅烧水滑石对海水海砂混凝土性能影响的研究[J].混凝土与水泥制品,2017(10):1-5.

QIAO Z, ZHANG L, WANG Z J,et al.Influence Research of Calcined Layerd Double Hydrixide on Performance of Seawater-seasand Concrete[J].China Concrete and Cement Products,2017(10):1-5.

摘要
参数
结论
参考文献
引用本文

摘   要: 通过分析阳极极化电位-时间曲线、Cl固结能力、水泥净浆的pH值来研究煅烧水滑石(CLDH)对海水海砂混凝土护筋性的影响,并与矿渣和粉煤灰进行比较。此外,还研究了煅烧水滑石对海水海砂混凝土力学性能的影响。结果表明,煅烧水滑石、矿渣、粉煤灰单掺掺量分别为6%、50%、20%时,海水海砂混凝土护筋性较好,Cl固结能力较好。护筋性与Cl固结能力呈现出良好的相关性。矿物掺合料掺量越高,水泥净浆pH越低;煅烧水滑石掺量越高,水泥净浆pH越高。改善海水海砂混凝土护筋性的能力依次为:煅烧水滑石>矿渣>粉煤灰,矿物掺合料对护筋性的影响十分有限。煅烧水滑石降低海水海砂混凝土的3d强度,但可增加海水海砂混凝土28d强度。

Abstract: The effect of CLDH (Calcined Layerd Double Hydrixide) on rebar-protecting properties of seawater-seasand concrete was studied by analyzing curve of rebar polarization and time, chloride ion combination, pH value of cement paste and compared with the effect of slag and fly ash. In addition, the mechanical properties of seawater-seasand concrete are also studied. The results show that when the CLDH content is 6%, the slag content is 50% and the fly ash content is 20%, rebar-protecting properties of seawater-seasand concrete is relatively superior, chloride ion combination is relatively superior. There is the good correlation between chloride ion combination and rebar-protecting properties.The more admixture content, the lower pH value of cement paste; The more CLDH content,the higher pH value of cement paste.The ability of improvement of rebar-protecting properties is in sequence of CLDH>slag>fly ash, the admixture has limited improvement on the rebar-protecting properties. CLDH can decrease the 3d strength of seawater-seasand concrete, but increase its 28d strength.

关键词:
海水海砂混凝土;极化电位;护筋性;掺合料;煅烧水滑石;强度
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)海砂海水混凝土随着CLDH掺量的增加,阳极极化电位-时间曲线逐步正移,净浆的pH值逐步提高,护筋性显著增强,但与淡水河沙混凝土相比,仍全部为腐蚀曲线,钢筋钝化膜依然被破坏,而矿渣和粉煤灰对海砂海水混凝土护筋性的改善更小;护筋性的改善能力依次为:CLDH>矿渣>粉煤灰。
(2)单位净浆的Cl-固结量及固结率随CLDH掺量的增加而增加,在掺量为6%时,分别达到6.65mg/g及58.68%,较海水海砂空白组提高102.1%;而矿渣和粉煤灰对Cl固结量及固结率较低,分别在掺量为50%、20%时,较海水海砂空白组提高14%和1.2%,且当粉煤灰掺量≥30%时,护筋性比海水海砂空白组更差。
(3)海水海砂混凝土3d强度高于淡水河砂混凝土,28d强度低于淡水河砂混凝土,二者均达到C40强度等级,海水海砂混凝土可用于素混凝土工程。CLDH可以通过固结部分Cl-来削弱Cl-的早强作用,并在一定程度上抑制海水海砂混凝土的收缩,因此,CLDH可以作为一种外加剂掺入混凝土。
[1] 张程浩.含Al2O3掺合料对水泥浆Cl-固定能力的影响及其机理[D].北京工业大学,2015.
[2] 洪乃丰.水环境腐蚀与混凝土的耐久性[J].腐蚀与防护,2006,27(4):174-177.
[3] Loser R, Lothenbach B,  Leemann A, et al. Chloride resistance of concrete and its binding capacity – Comparison between experimental results and thermodynamic modeling[J]. Cement & Concrete Composites,2010,32(1):34-42.
[4] Cheewaket T, Jaturapitakkul C, Chalee W. Long term performance of chloride binding capacity in fly ash concrete in a marine environment[J].Construction & Building Materials, 2010,24(8):1352-1357.
[5] Thomas M D A, Hooton R D, Scott A, et al. The effect of supplementary cementitious materials on chloride binding in hardened cement paste[J]. Cement & Concrete Research, 2012, 42(1):1-7.
[6] Nielsen E P, Herfort D, Geiker M R. Binding of chloride and alkalis in Portland cement systems[J]. Cement & Concrete Research,2005,35(1):117-123.
[7] Zibara H, Hooton R D, Thomas M D A, et al. Influence of the C/S and C/A ratios of hydration products on the chloride ion binding capacity of lime-SF and lime-MK mixtures[J]. Cement & Concrete Research,2008,38(3):422-426.
[8] 方瑞良,周廷容,雷淑敏.矿物掺合料对硬化混凝土水泥浆体孔溶液碱度影响的探索[C].全国混凝土膨胀剂学术交流会暨中国混凝土与水泥制品协会膨胀混凝土分会年会,2014.
[9] Vaccari A. Preparation and Catalytic Properties of Cationic and Anionic Clays[J]. Catalysis Today,1998, 41(1-3):53-71.
[10] Lv L, He J, Wei M, et al. Uptake of chloride ion from aqueous solution by calcined layered double hydroxides: equilibrium and kinetic studies[J].Water Research,2006,40(4):735-43.
[11] Oemajtis  J, Weyers R E, Chair T E, et al. Modeling the Time to Corrosion Initiation for Concretes with Mineral Admixtures and/or Corrosion Inhibitors in Chloride-Laden Environments[J].1998.
[12] Sato T, Wakabayashi T, Shimada M. Adsorption of various anions by magnesium aluminum oxide of (Mg0.7Al0.3O1.15)[J]. Industrial & Engineering Chemistry Product Research & Development,1986,25(1):89-92.
[13] 吴中伟,廉慧珍.高性能混凝土[M].北京:中国铁道出版社,1999.

乔治,张磊,王志杰,.煅烧水滑石对海水海砂混凝土性能影响的研究[J].混凝土与水泥制品,2017(10):1-5.

QIAO Z, ZHANG L, WANG Z J,et al.Influence Research of Calcined Layerd Double Hydrixide on Performance of Seawater-seasand Concrete[J].China Concrete and Cement Products,2017(10):1-5.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州