苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
工业灰渣-陶粒新型混凝土配合比试验研究
Experimental Research on Mix Proportion of New Industrial Solid Waste-ceramsite Concrete
2017年第10期
工业灰渣;表观密度;软化系数;抗压强度;导热系数
Industrial solid waste; Apparent density; Softening coefficient; Compressive strength; Thermal conductivity
2017年第10期
1000-4637(2017)10-66-04
国家自然科学基金项目(51468057)
夏多田,吕开清,朱清峰,何明胜
石河子大学水利建筑工程学院,832000

夏多田,吕开清,朱清峰,何明胜

夏多田,吕开清,朱清峰,等.工业灰渣-陶粒新型混凝土配合比试验研究[J].混凝土与水泥制品,2017(10):66-69.

XIA D T, LYU K Q, ZHU Q F,et al.Experimental Research on Mix Proportion of New Industrial Solid Waste-ceramsite Concrete[J].China Concrete and Cement Products,2017(10):66-69.

浏览量:
1000
摘 要:通过正交试验研究了砂率、脱硫灰替代率、脱硫石膏替代率和微硅粉替代率四个因素对新型混凝土干表观密度、软化系数、导热系数、绝干抗压强度以及吸水率5个指标的影响。结果表明:各因素对新型混凝土5个试验指标的影响顺序为:脱硫石膏C>脱硫灰B>砂率A>微硅粉D。综合平衡分析各因素对新型混凝土5个试验指标的影响,确定了工业灰渣-陶粒新型混凝土的最优配合比。 Abstract: The influence of four factors on the dry density, softening coefficient, thermal conductivity, dry compressive strength and water absorption of new concrete were studied by orthogonal test. The four factors are the sand ratio, the replacement rate of desulfurization ash, the replacement rate of desulfurization gypsum and the replacement rate of silica fume. The results show that the influence order of all factors on the five test indicators of the new concrete was desulfurization gypsum C>desulfurization ash B> sand rate A> micro silica powder D. The optimal mixture ratio is determined by analyzing the influence of all factors on the five test indicators of the new concrete.
英文名 : Experimental Research on Mix Proportion of New Industrial Solid Waste-ceramsite Concrete
刊期 : 2017年第10期
关键词 : 工业灰渣;表观密度;软化系数;抗压强度;导热系数
Key words : Industrial solid waste; Apparent density; Softening coefficient; Compressive strength; Thermal conductivity
刊期 : 2017年第10期
DOI :
文章编号 : 1000-4637(2017)10-66-04
基金项目 : 国家自然科学基金项目(51468057)
作者 : 夏多田,吕开清,朱清峰,何明胜
单位 : 石河子大学水利建筑工程学院,832000

夏多田,吕开清,朱清峰,何明胜

夏多田,吕开清,朱清峰,等.工业灰渣-陶粒新型混凝土配合比试验研究[J].混凝土与水泥制品,2017(10):66-69.

XIA D T, LYU K Q, ZHU Q F,et al.Experimental Research on Mix Proportion of New Industrial Solid Waste-ceramsite Concrete[J].China Concrete and Cement Products,2017(10):66-69.

摘要
参数
结论
参考文献
引用本文

摘   要:通过正交试验研究了砂率、脱硫灰替代率、脱硫石膏替代率和微硅粉替代率四个因素对新型混凝土干表观密度、软化系数、导热系数、绝干抗压强度以及吸水率5个指标的影响。结果表明:各因素对新型混凝土5个试验指标的影响顺序为:脱硫石膏C>脱硫灰B>砂率A>微硅粉D。综合平衡分析各因素对新型混凝土5个试验指标的影响,确定了工业灰渣-陶粒新型混凝土的最优配合比。

Abstract: The influence of four factors on the dry density, softening coefficient, thermal conductivity, dry compressive strength and water absorption of new concrete were studied by orthogonal test. The four factors are the sand ratio, the replacement rate of desulfurization ash, the replacement rate of desulfurization gypsum and the replacement rate of silica fume. The results show that the influence order of all factors on the five test indicators of the new concrete was desulfurization gypsum C>desulfurization ash B> sand rate A> micro silica powder D. The optimal mixture ratio is determined by analyzing the influence of all factors on the five test indicators of the new concrete.

关键词:
工业灰渣;表观密度;软化系数;抗压强度;导热系数
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)脱硫石膏是影响工业灰渣-陶粒混凝土5个指标最主要、最显著的因素。
(2)各因素影响工业灰渣-陶粒混凝土5个试验指标的主次顺序为:脱硫石膏(C)>脱硫灰(B)>砂率(A)>微硅粉(D)。
(3)工业灰渣-陶粒混凝土基于5个试验指标的最优组合是A1B2C1D2,即砂率为10%,脱硫灰替代粉煤灰为10%,脱硫石膏替代粉煤灰为30%,微硅粉替代水泥为5%。
(4)利用工业灰渣作为轻质陶粒混凝土的掺合料是完全可行的,工业灰渣-陶粒混凝土可以作为制作轻质砌块和轻质墙板等建筑墙体材料使用。
[1] 高英力,陈瑜,王迪,等.脱硫石膏-粉煤灰活性掺合料设计及水化特性[J].四川大学学报:工程科学版,2010,2(42):225-231.
[2] 陈瑜,高英力.粉煤灰脱硫石膏复合胶凝材料的配合比与水化[J].建筑材料学报,2012,15(2):283-288.
[3] 周君生,徐伟,陈益兰,等.利用工业废渣生产多微孔胶凝材料的研究[J].无机盐工业,2012,44(9):39-41.
[4] 周君生.利用工业废渣生产多微孔胶凝材料的研究[D].南宁:广西大学,2012.
[5] 陈友治,李国刚,毕春梅,等.利用矿渣、脱硫渣及炉渣制备胶凝材料试验研究[J].武汉理工大学学报,2010,32(14):6-10.
[6] 张超.粉煤灰和炉渣作水泥混合材及粉煤灰掺量对不同水胶比混凝土的强度影响研究[D].西安:西安建筑科技大学,2012.
[7] 杨长利.干混砂浆专用胶凝材料的性能研究[D].郑州:郑州大学,2012.
[8] 吴彻平,彭家惠,瞿金东,等.新型脱硫石膏基保温砂浆的配制及性能研究[J].材料导报B(研究篇),2010,25(10):121-124. 
[9] 孔祥香.脱硫石膏基加气混凝土的研究[D].武汉:武汉理大学,2009.
[10] 王雨利,刘素霞,罗树琼,等.利用固体废弃物制备蒸压加气混凝土砌块的研究[J].河南理工大学学报:自然科学版,2012, 31(5):613-616.
[11] 刘素霞,王雨利,罗树琼,等.利用工业废渣生产新型墙体材料的试验研究[J].新型建筑材料,2012(11):59-62.
[12] 梁宝瑞,宋存义,毛妍妮,等.脱硫灰用作钙质材料制备蒸压加气混凝土砖块[J].环境工程学报,2012,6(4):1358-1362.
[13] 周飞,杨久俊,王芳.改性脱硫建筑石膏加气砌块制备工艺参数及其对性能的影响[J].新型建筑材料,2012(6):20-23.
[14] 路国忠,周丽娟,陈建超.轻质高强脱硫石膏砌块的制备技术[J].新型建筑材料,2011(8):25-28.
[15] 吕开清,夏多田.新型陶粒混凝土材料配合比试验研究[J].混凝土,2017(4):147-150.

夏多田,吕开清,朱清峰,.工业灰渣-陶粒新型混凝土配合比试验研究[J].混凝土与水泥制品,2017(10):66-69.

XIA D T, LYU K Q, ZHU Q F,et al.Experimental Research on Mix Proportion of New Industrial Solid Waste-ceramsite Concrete[J].China Concrete and Cement Products,2017(10):66-69.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州