苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
超高分子量聚乙烯纤维混凝土工作性及耐久性研究
Study on Workability and Durability of Ultra-high Molecular Weight Polyethylene(UHMWPE) Fiber Concrete
2016年第1期
超高分子量聚乙烯;混凝土;工作性;氯离子渗透;抗冲磨
Ultra-high molecular weight polyethylene fiber; Concrete; Workability; Chloride permeability; Abrasion resistance
2016年第1期
1000-4637(2016)01-50-04
国家自然科学基金项目(51279054);江苏省普通高校研究生科研创新计划项目(1044/B14053)
边 策1,田正宏1,高林冬2,吴 军3
1.河海大学水利水电学院,南京 210098;2.中国电建集团华东勘测设计研究院 有限公司,杭州 650000;3.中国水利水电第七工程局有限公司,成都 610081

边 策1,田正宏1,高林冬2,吴 军3

浏览量:
1000
摘 要:通过超高分子量聚乙烯纤维混凝土坍落度、离析度、氯离子渗透、抗冲磨试验,分析了纤维掺量和长度对混凝土工作性及耐久性的影响。结果表明,掺入超高分子量聚乙烯纤维后,混凝土流动性降低,但均匀性、抗渗性和抗冲磨性能提高较大,其中短纤维对性能改善最明显。相比无纤维素混凝土,短纤维掺量达到0.15%时,氯离子渗透等级降低一个数量级,而在0.2%时,抗冲磨强度提高约42%。 Abstract: The influences of fiber amount and length on workability and durability of concrete are analyzed through the test for slump value, segregation coefficient(SC), chloride permeability and abrasion resistance of ultra-high molecular weight polyethylene (UHMWPE) fiber concrete. The results show that the fluidity of concrete by adding UHMPE fiber decreases whereas its intrinsic homogeneity, impermeability and abrasion resistance performance increase greatly, especially the effect of short fiber on the properties is the most obvious. considerably. Comparing with ordinary concrete, short fiber content reaches 0.15%, the chloride ion penetration level reduce an order of magnitude, the impact strength increase about 42% when short fiber content reaches reaches 0.2%.
英文名 : Study on Workability and Durability of Ultra-high Molecular Weight Polyethylene(UHMWPE) Fiber Concrete
刊期 : 2016年第1期
关键词 : 超高分子量聚乙烯;混凝土;工作性;氯离子渗透;抗冲磨
Key words : Ultra-high molecular weight polyethylene fiber; Concrete; Workability; Chloride permeability; Abrasion resistance
刊期 : 2016年第1期
DOI :
文章编号 : 1000-4637(2016)01-50-04
基金项目 : 国家自然科学基金项目(51279054);江苏省普通高校研究生科研创新计划项目(1044/B14053)
作者 : 边 策1,田正宏1,高林冬2,吴 军3
单位 : 1.河海大学水利水电学院,南京 210098;2.中国电建集团华东勘测设计研究院 有限公司,杭州 650000;3.中国水利水电第七工程局有限公司,成都 610081

边 策1,田正宏1,高林冬2,吴 军3

摘要
参数
结论
参考文献
引用本文

摘   要:通过超高分子量聚乙烯纤维混凝土坍落度、离析度、氯离子渗透、抗冲磨试验,分析了纤维掺量和长度对混凝土工作性及耐久性的影响。结果表明,掺入超高分子量聚乙烯纤维后,混凝土流动性降低,但均匀性、抗渗性和抗冲磨性能提高较大,其中短纤维对性能改善最明显。相比无纤维素混凝土,短纤维掺量达到0.15%时,氯离子渗透等级降低一个数量级,而在0.2%时,抗冲磨强度提高约42%。

Abstract: The influences of fiber amount and length on workability and durability of concrete are analyzed through the test for slump value, segregation coefficient(SC), chloride permeability and abrasion resistance of ultra-high molecular weight polyethylene (UHMWPE) fiber concrete. The results show that the fluidity of concrete by adding UHMPE fiber decreases whereas its intrinsic homogeneity, impermeability and abrasion resistance performance increase greatly, especially the effect of short fiber on the properties is the most obvious. considerably. Comparing with ordinary concrete, short fiber content reaches 0.15%, the chloride ion penetration level reduce an order of magnitude, the impact strength increase about 42% when short fiber content reaches reaches 0.2%.

关键词:
超高分子量聚乙烯;混凝土;工作性;氯离子渗透;抗冲磨
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)混凝土坍落度随着UHMWPE纤维掺量的增加而逐渐减小,且在相同掺量下,拌合物中纤维长度与坍落度成正比关系。
(2)纤维可以改善混凝土拌合物离析问题,由此提高纤维分布均匀性,同时,纤维越短,混凝土离析度越低,纤维分布越均匀。
(3)由于UHMWPE纤维的阻裂增韧和引气作用,使得纤维掺量越大,长度越低,混凝土氯离子抗渗性能越强。
(4) 掺入UHMWPE纤维可以提高混凝土抗冲磨性能,且短纤维提高性能更为明显。
[1] 丁道红,章青.混凝土缺陷研究综述[J].混凝土,2009,240(10):16-18.
[2] 赵铁军.高性能混凝土的渗透性研究[J].混凝土与水泥制品,1997,93(1):16-19.
[3] 张育宁.高强高性能纤维混凝土及其性能与应用研究[D].上海:同济大学,2010.
[4] Kamada T, Li V C. The effects of surface preparation on the fracture behavior of ECC/concrete repair system[J].Cement and Concrete Composites,2000,22(6):423-431.
[5] 晏麓晖,张玉武,朱林.超高分子量聚乙烯纤维混凝土的基本力学性能[J].国防科技大学学报,2014,36(6):43-47.
[6] 郑逢时.UHMWPE纤维表面处理及其水泥砂浆性能研究[D].西安:长安大学,2014.
[7] 余红发,孙伟,张云升.高强高模聚乙烯纤维对大掺量矿物掺合料高强混凝土抗冻性的影响[J].南京航空航天大学学报,2008,40(3):399-403.
[8] 余红发,刘俊龙,李美,等.FRHPC在冻融与腐蚀共同作用下的强度变化[J].沈阳建筑大学学报,2006,22(2):272-276.
[9] 中华人民共和国水利部. SL 352—2006水工混凝土试验规程[S].北京:中国水利水电出版社,2006.
[10] Safawi M I, Iwaki I, Miura T. A Study on the applicability of vibration in fresh high fluidity concrete[J]. Cement and Concrete Research,2005,35(9):1834-1845.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州