苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
纤维增强免压蒸PHC管桩混凝土的抗冲击性能研究
Research on Impact Resistance Properties of Fiber Reinforced Non-autoclaving PHC Pile Concrete
2016年第5期
免压蒸;PHC管桩;钢纤维;聚丙烯纤维;聚乙烯醇纤维;冲击性能
Non-autoclaving; PHC pile; Steel fiber; Polypropylene fiber; Polyvinyl alcohol fiber; Impact resistance property
2016年第5期
1000-4637(2016)05-32-04
国家973项目(2015CB655104)。
黄 凯,高 鹏,张亚梅
(东南大学材料科学与工程学院,江苏省土木工程材料重点试验室,南京 211189

黄 凯,高 鹏,张亚梅

浏览量:
1000
摘 要:研究了钢纤维(SF)、聚丙烯纤维(PP)和聚乙烯醇纤维(PVA)对免压蒸PHC管桩用混凝土的力学性能及抗冲击性能的影响。结果表明:PP纤维、PVA纤维和SF的加入提高了混凝土的抗压强度和抗折强度,其中,SF的提升效果最大,平均抗压强度高出空白组15MPa,PP纤维和PVA纤维的提升效果不太明显;SF的加入大大提高了蒸养混凝土平板的抗冲击性能,PP纤维的加入对抗冲击性能也有一定程度的提高,PVA纤维略微降低了混凝土平板的抗冲击性能;SF混凝土板的抗冲击性能随W/C变化不大,其他纤维混凝土板的抗冲击性能随W/C增加而降低。 Abstract: The mechanical properties and impact resistance of non-autoclaving PHC concrete with steel fibers (SF), polypropylene fibers (PP) and polyvinyl alcohol fibers (PVA) are investigated. The results show that all the three fibers can enhance the compressive strength and flexured strength of the concrete, in which the compressive strength of concrete with SF is the highest, 15MPa higher than the contrast one. Furthermore, when SF is added in to non-autoclaving PHC pile concrete, the impact resistance properties are greatly improved. The impact resistance properties of concrete with PP can also be enhanced to a certain extent, however PVA will reduce the impact resistance properties of non-autoclaving PHC pile concrete. When the W/C is reduced, the impact resistance properties of concrete with SF changes a little, but concrete with other two fibers have lower impact resistance properties along with the W/C is reduced.
英文名 : Research on Impact Resistance Properties of Fiber Reinforced Non-autoclaving PHC Pile Concrete
刊期 : 2016年第5期
关键词 : 免压蒸;PHC管桩;钢纤维;聚丙烯纤维;聚乙烯醇纤维;冲击性能
Key words : Non-autoclaving; PHC pile; Steel fiber; Polypropylene fiber; Polyvinyl alcohol fiber; Impact resistance property
刊期 : 2016年第5期
DOI :
文章编号 : 1000-4637(2016)05-32-04
基金项目 : 国家973项目(2015CB655104)。
作者 : 黄 凯,高 鹏,张亚梅
单位 : (东南大学材料科学与工程学院,江苏省土木工程材料重点试验室,南京 211189

黄 凯,高 鹏,张亚梅

摘要
参数
结论
参考文献
引用本文

摘   要:研究了钢纤维(SF)、聚丙烯纤维(PP)和聚乙烯醇纤维(PVA)对免压蒸PHC管桩用混凝土的力学性能及抗冲击性能的影响。结果表明:PP纤维、PVA纤维和SF的加入提高了混凝土的抗压强度和抗折强度,其中,SF的提升效果最大,平均抗压强度高出空白组15MPa,PP纤维和PVA纤维的提升效果不太明显;SF的加入大大提高了蒸养混凝土平板的抗冲击性能,PP纤维的加入对抗冲击性能也有一定程度的提高,PVA纤维略微降低了混凝土平板的抗冲击性能;SF混凝土板的抗冲击性能随W/C变化不大,其他纤维混凝土板的抗冲击性能随W/C增加而降低。

Abstract: The mechanical properties and impact resistance of non-autoclaving PHC concrete with steel fibers (SF), polypropylene fibers (PP) and polyvinyl alcohol fibers (PVA) are investigated. The results show that all the three fibers can enhance the compressive strength and flexured strength of the concrete, in which the compressive strength of concrete with SF is the highest, 15MPa higher than the contrast one. Furthermore, when SF is added in to non-autoclaving PHC pile concrete, the impact resistance properties are greatly improved. The impact resistance properties of concrete with PP can also be enhanced to a certain extent, however PVA will reduce the impact resistance properties of non-autoclaving PHC pile concrete. When the W/C is reduced, the impact resistance properties of concrete with SF changes a little, but concrete with other two fibers have lower impact resistance properties along with the W/C is reduced.

关键词:
免压蒸;PHC管桩;钢纤维;聚丙烯纤维;聚乙烯醇纤维;冲击性能
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)SF的加入能够显著提高管桩用免压蒸混凝土的抗压强度,抗折强度也有所提高。当W/C为0.28时,SF对混凝土的7d抗压强度比素混凝土要高出14MPa;W/C=0.30时,SF对强度的提升效果较W/C=0.28有所下降。PP纤维和PVA纤维对蒸养混凝土的抗压强度也有所提升,但效果较SF差;对抗折强度的影响则不是很显著。
(2)SF的加入能够大幅度提高混凝土的抗冲击性能,其抗冲击性能接近素混凝土抗冲击性能的两倍,且SF混凝土的抗冲击性能随纤维掺量的增加而有所提高;PP纤维对混凝土的抗冲击性能也有提高,但其提升效果较SF差;PVA纤维混凝土板的抗冲击性能最差,PVA纤维的加入反而降低了混凝土的抗冲击性能。
(3)混凝土的抗冲击性能随W/C的增加略有下降。其中,SF混凝土的抗冲击性能下降不明显,素混凝土与掺PP纤维的冲击性能下降幅度则较大。
[1] 王成启,王春明,周郁兵,等.养护方式对PHC管桩力学性能的影响[J].中国港湾建设,2014(5):28-31.
[2] 张建纲,毛永琳,乔敏. PHC管桩混凝土免压蒸技术研究[J]. 混凝土与水泥制品,2012(7):31-33.
[3] 薛利俊,李斌斌.矿物掺和料对PHC管桩混凝土耐久性性能影响的研究[J]. 建材发展导向,2014(4):47-49.
[4] 汪梁.C80免压蒸管桩混凝土的研究[J].粉煤灰,2015(2):33-34.
[5] 吴丽杰.浅谈PHC桩桩基工程的质量控制[J]. 建材与装饰(下旬刊),2008(5):148-150.
[6] 李为民,许金余,翟毅,等.冲击荷载作用下碳纤维混凝土的力学性能[J].土木工程学报,2009,42(2):24-30.
[7] 胡金生,杨秀敏,周早生,等.钢纤维混凝土与聚丙烯纤维混凝土材料冲击荷载下纤维增韧特性试验研究[J].建筑结构学报,2005(2):101-105.
[8] 王晨飞.氯盐环境下聚丙烯纤维混凝土耐久性能研究[D]. 西安:西安建筑科技大学,2012.
[9] 罗章,李启月,凌同华.钢纤维混凝土的工程应用研究[J].江西有色金属,2003(2):12-15.
[10] 龚益,沈荣熹, 李清海. 杜拉纤维在土建工程中的应用[M].北京:机械工业出版社,2002.
[11] 张彬.浅议预应力混凝土管桩锤击法施工技术[J].山西建筑,2011,37(1):58-59.
[12] 黄炜.PHC桩基施工中出现Ⅲ类、Ⅳ类桩的原因分析及补强处理[J].建筑施工,2015(1):57-59.
 

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州