苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
冷却方式对高温后水泥石物相组成的影响
Effects of Cooling Ways on the Phase and Composition of Hardened Cement after High Temperature[J].
2018年第2期
水泥石;高温;水冷却;静置;碳化;混凝土;裂缝;X衍射分析;热分析
Hardened cement paste;High temperature;Water cooling;Standing;Carbonization; Concrete; Crack; X-ray diffraction (XRD); Thermoan
2018年第2期
1000-4637(2018)02-17-05
中央公益性科研院所基本科研业务费专项资金(Y416013、Y416018);江苏省水利科技项目(2015013)。
韦 华1,冯小忠2,束 伟1,钱文勋1
1.南京水利科学研究院 水文水资源与水利工程科学国家重点实验室,210029; 2.江苏省水利工程建设局,南京 210029

韦 华1,冯小忠2,束 伟1,钱文勋1

韦华,冯小忠,束伟,等.冷却方式对高温后水泥石物相组成的影响[J].混凝土与水泥制品,2018(2):17-21.

WEI H,FENG X Z,SU W,et al.Effects of Cooling Ways on the Phase and Composition of Hardened Cement after High Temperature[J].China Concrete and Cement Products,2018(2):17-21.

浏览量:
1000
摘 要:借助X衍射分析(XRD)及综合热分析(TG-DTA)技术,研究了水泥石在高温(300~600℃)水冷后的物相组成变化。结果表明:高温后,不同条件下的水泥石除不同程度的脱水分解外,均出现了二次水化及严重碳化,其碳化程度由低到高为:自然冷却、水冷却、水冷后静置;破坏样中Ca(OH)2和CaCO3质量分数受Ca(OH)2分解温度范围影响显著。Abstract:Scholarshavegivenwideattentiononcoolingmethodstoheatdegradationmechanismofconcrete,butthephysicalandchemicalchangesintheprocessofwatercoolingandstandingisnotclear.Thephaseandcompositionofhardenedcementpasteathightemperature(300~600℃)afterwatercoolingunderdifferentconditionswereanalyzedbyusingX-raydiffraction(XRD)andthermoanalysistechnology(TG-DTA).Theresultsshowthat,afterthehightemperature,differenthardenedcementpasteundertheconditionhasthedifferentlevelsofdecompositionofdehydration,secondaryhydrationandseverecarbonization,andthedegreeofcarbonizationfromlowtohighasfollows:naturalcooling,watercooling,standingafterwater;themassfractionofCa(OH)2andCaCO3inthedestructivesamplehaveremarkableeffectbyCa(OH)2decompositiontemperaturerange.
英文名 : Effects of Cooling Ways on the Phase and Composition of Hardened Cement after High Temperature[J].
刊期 : 2018年第2期
关键词 : 水泥石;高温;水冷却;静置;碳化;混凝土;裂缝;X衍射分析;热分析
Key words : Hardened cement paste;High temperature;Water cooling;Standing;Carbonization; Concrete; Crack; X-ray diffraction (XRD); Thermoan
刊期 : 2018年第2期
DOI :
文章编号 : 1000-4637(2018)02-17-05
基金项目 : 中央公益性科研院所基本科研业务费专项资金(Y416013、Y416018);江苏省水利科技项目(2015013)。
作者 : 韦 华1,冯小忠2,束 伟1,钱文勋1
单位 : 1.南京水利科学研究院 水文水资源与水利工程科学国家重点实验室,210029; 2.江苏省水利工程建设局,南京 210029

韦 华1,冯小忠2,束 伟1,钱文勋1

韦华,冯小忠,束伟,等.冷却方式对高温后水泥石物相组成的影响[J].混凝土与水泥制品,2018(2):17-21.

WEI H,FENG X Z,SU W,et al.Effects of Cooling Ways on the Phase and Composition of Hardened Cement after High Temperature[J].China Concrete and Cement Products,2018(2):17-21.

摘要
参数
结论
参考文献
引用本文
摘  要:借助X衍射分析(XRD)及综合热分析(TG-DTA)技术,研究了水泥石在高温(300~600℃)水冷后的物相组成变化。结果表明:高温后,不同条件下的水泥石除不同程度的脱水分解外,均出现了二次水化及严重碳化,其碳化程度由低到高为:自然冷却、水冷却、水冷后静置;破坏样中Ca(OH)2和CaCO3质量分数受Ca(OH)2分解温度范围影响显著。
Abstract:Scholars have given wide attention on cooling methods to heat degradation mechanism of concrete, but the physical and chemical changes in the process of water cooling and standing is not clear. The phase and composition of hardened cement paste at high temperature (300600℃) after water cooling under different conditions were analyzed by using X-ray diffraction (XRD) and thermoanalysis technology (TG-DTA). The results show that, after the high temperature, different hardened cement paste under the condition has the different levels of decomposition of dehydration, secondary hydration and severe carbonization, and the degree of carbonization from low to high as follows: natural cooling, water cooling, standing after water; the mass fraction of Ca(OH)2 and CaCO3 in the destructive sample have remarkable effect by Ca(OH)2 decomposition temperature range.
关键词:
水泥石;高温;水冷却;静置;碳化;混凝土;裂缝;X衍射分析;热分析
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)高温自然冷却后,水泥石整体变酥,静置后发生破碎;喷水冷却及喷水后静置,虽然促进了水泥石中未水化水泥进一步水化,但随着热致裂纹的发展,其黏结力作用也不复存在。
(2)不同条件下的HCP在高温(300600℃)下出现不同程度的脱水分解、水化及碳化;高温后,不同条件下的水泥石均出现二次水化及严重碳化,其碳化程度由低到高为:自然冷却、水冷却及3d静置。
(3)温度是水泥石中水化产物物相组成变化的主要因素,不同条件下,破坏样中CH和CaCO3质量分数受CH分解温度范围影响较明显。相对较低的高温(300~400℃)下,碳化产物CaCO3来源除CH外,还有大量C-S-H;随温度上升,CH与CaCO3质量分数数值达其极值,趋于稳定。
[1] 阎继红,林志伸.高温作用后混凝土抗压强度的试验研究[J].土木工程学报,2002,35(5):17-19.
[2] 孙伟.高性能混凝土的高温性能研究[J].建筑材料学报,2000,3(1):27-32.
[3] 陈映贞,许肇峰,王勇平,等.高温(火灾)作用后混凝土残余强度统计分析[J].混凝土与水泥制品,2016(9):1-5. 
[4] Chan Y N, Luo X, Sun W. Compressive strength and pore structure of high-performance concrete after exposure to high temperature up to 800℃[J].Cement & Concrete Research,2000,30(2):247-251.
[5] Pineaud A, Pimienta P, Rémond S, et al. Mechanical properties of high performance self-compacting concretes at room and high temperature[J].Construction & Building Materials,2016,112:747-755.
[6] 李卫,过镇海.高温下砼的强度和变形性能试验研究[J].建筑结构学报,1993,14(1):8-16.
[7] 胡海涛,董毓利,刘伊琳.高强混凝土在高温中和高温后的抗压强度试验研究[J].混凝土与水泥制品,2004(1):18-20.
[8] 张桥,刘改利,成聪慧,等.基于XRD对高强混凝土高温后力学试验研究[J].混凝土与水泥制品,2015(3):9-11.
[9] Peng G F, Bian S H, Guo Z Q, et al. Effect of thermal shock due to rapid cooling on residual mechanical properties of fiber concrete exposed to high temperatures[J]. Construction & Building Materials,2008,22(5):948-955.
[10] 吕天启,赵国藩,林志伸,等.高温后静置混凝土的微观分析[J]. 建筑材料学报,2003,6(2):135-141.
[11] 翟越,艾晓芹,邓子辰,等.受火温度和冷却方式对混凝土抗压强度影响[J].湖南大学学报:自科版,2014,41(11):74-80.
[12] Fares H, Remond S, Noumowe A, et al. High temperature behaviour of self-consolidating concrete : Microstructure and physicochemical properties[J]. Cement & Concrete Research,2010,40(3):488-496.
[13] 柳献,袁勇,叶光,等.高性能混凝土高温微观结构演化研究[J].同济大学学报:自然科学版,2008,36(11):1473-1478.
[14] 朋改非,王金羽,CHANYinNinSammy,等.火灾高温下硬化水泥浆的化学分解特征[J].南京信息工程大学学报,2009(1):76-81.
[15] 廉慧珍,童良,陈恩义.建筑材料物相研究基础[M].北京:清华大学出版社,1996.
[16] 郭斌,闵盘荣,王国宾.水化硅酸钙的碳化作用[J].硅酸盐学报,1984(3):31-39,133.
[17] Villain G, Thiery M, Platret G. Measurement methods of carbonation profiles in concrete: Thermogravimetry, chemical analysis and gammadensimetry[J]. Cement and Concrete Research, 2007,37(8):1182-1192.
[18] 何娟,杨长辉.硅酸盐水泥混凝土的碳化分析[J].硅酸盐通报,2009,28(6):1225-1229.
[19] 谭银龙.高温后混凝土性能促进恢复及其机理研究[D].北京:中国矿业大学,2014.
[20] 万夫雄,孙本尧,海维深,等.火灾高温后混凝土的强度恢复试验[J].混凝土,2016(10):30-32.

韦华,冯小忠,束伟,.冷却方式对高温后水泥石物相组成的影响[J].混凝土与水泥制品,2018(2):17-21.

WEI H,FENG X Z,SU W,et al.Effects of Cooling Ways on the Phase and Composition of Hardened Cement after High Temperature[J].China Concrete and Cement Products,2018(2):17-21.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州