苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
钢纤维含量对高性能混凝土断裂性能影响的试验研究及评价分析
Experimental Study and Evaluation Analysis on Influence of Steel Fiber Content on Toughness Properties of High Performance Concr
2018年第2期
高性能钢纤维混凝土;钢纤维掺量;断裂韧性;力学性能
Steel fiber reinforced high performance concrete; Steel fiber content; Fracture toughness; Mechanical properties
2018年第2期
1000-4637(2018)02-50-05
河南省交通厅科技项目(2016Y2-1);河南省教育厅项目(14A560002);河南省博士后基金项目(169440)。
丁亚红1,马金一1,徐 平1,张长林2,薛宝贵3
1.河南理工大学土木工程学院,焦作 454003;2.河南省交通运输厅公路管理局,郑州 450000; 3.方正公路工程监理咨询公司,新乡 453000

丁亚红1,马金一1,徐 平1,张长林2,薛宝贵3

丁亚红,马金一,徐平,等.钢纤维含量对高性能混凝土断裂性能影响的试验研究及评价分析[J].混凝土与水泥制品,2018(2):50-54.

DING Y H,MA J Y,XU P,et al.Experimental Study and Evaluation Analysis on Influence of Steel Fiber Content on Toughness Properties of High Performance Concrete[J].China Concrete and Cement Products,2018(2):50-54.

浏览量:
1000
摘 要:为研究不同掺量钢纤维对高性能混凝土断裂韧度的影响,对高性能纤维混凝土单边切口梁进行了三点弯曲试验,共进行了三组不同掺量的钢纤维混凝土单边切口试件的断裂试验及混凝土基本物理力学性能试验,并根据双K断裂准则进行韧度计算。结果表明,钢纤维的掺量是影响高性能混凝土断裂韧度的一个重要影响因素。高性能混凝土的断裂韧度随着钢纤维掺量的增加而提高,其中,钢纤维掺量为2%和4% 的混凝土,其断裂韧度平均值分别是不掺量混凝土的9.5倍和10.6倍。在固定基质混凝土配合比条件下,钢纤维掺量为2%时,高性能混凝土的抗压强度、抗弯强度、流动性、以及断裂韧度等性能综合最优。 Abstract: In order to study the effect of steel fiber content on the fracture toughness of high performance concrete, three-point bending tests of single edge notched beams made of steel fiber reinforced high performance concrete(SFHPC) were performed. The basic physical parameters of concrete were obtained by experiments. Meanwhile, fracture toughness of high performance concrete with different steel fiber content were determined by three-point bending tests and double-K fracture criterion. The results show that the content of steel fiber is an important factor that influences the fracture toughness of high performance concrete. The fracture toughness of high performance concrete increases with the increasing of steel fiber content, and the average fracture toughness of concrete with steel fiber content of 2% and 4% is 9.5 and 10.6 times to the content of 0 respectively. In the fixed matrix concrete mix ratio conditions, the compressive strength, fluidity, and fracture toughness of high performance concrete are optimized with the steel fiber content of 2%.
英文名 : Experimental Study and Evaluation Analysis on Influence of Steel Fiber Content on Toughness Properties of High Performance Concr
刊期 : 2018年第2期
关键词 : 高性能钢纤维混凝土;钢纤维掺量;断裂韧性;力学性能
Key words : Steel fiber reinforced high performance concrete; Steel fiber content; Fracture toughness; Mechanical properties
刊期 : 2018年第2期
DOI :
文章编号 : 1000-4637(2018)02-50-05
基金项目 : 河南省交通厅科技项目(2016Y2-1);河南省教育厅项目(14A560002);河南省博士后基金项目(169440)。
作者 : 丁亚红1,马金一1,徐 平1,张长林2,薛宝贵3
单位 : 1.河南理工大学土木工程学院,焦作 454003;2.河南省交通运输厅公路管理局,郑州 450000; 3.方正公路工程监理咨询公司,新乡 453000

丁亚红1,马金一1,徐 平1,张长林2,薛宝贵3

丁亚红,马金一,徐平,等.钢纤维含量对高性能混凝土断裂性能影响的试验研究及评价分析[J].混凝土与水泥制品,2018(2):50-54.

DING Y H,MA J Y,XU P,et al.Experimental Study and Evaluation Analysis on Influence of Steel Fiber Content on Toughness Properties of High Performance Concrete[J].China Concrete and Cement Products,2018(2):50-54.

摘要
参数
结论
参考文献
引用本文
摘  要:为研究不同掺量钢纤维对高性能混凝土断裂韧度的影响,对高性能纤维混凝土单边切口梁进行了三点弯曲试验,共进行了三组不同掺量的钢纤维混凝土单边切口试件的断裂试验及混凝土基本物理力学性能试验,并根据双K断裂准则进行韧度计算。结果表明,钢纤维的掺量是影响高性能混凝土断裂韧度的一个重要影响因素。高性能混凝土的断裂韧度随着钢纤维掺量的增加而提高,其中,钢纤维掺量为2%和4% 的混凝土,其断裂韧度平均值分别是不掺量混凝土的9.5倍和10.6倍。在固定基质混凝土配合比条件下,钢纤维掺量为2%时,高性能混凝土的抗压强度、抗弯强度、流动性、以及断裂韧度等性能综合最优。
Abstract: In order to study the effect of steel fiber content on the fracture toughness of high performance concrete, three-point bending tests of single edge notched beams made of steel fiber reinforced high performance concrete(SFHPC) were performed. The basic physical parameters of concrete were obtained by experiments. Meanwhile, fracture toughness of high performance concrete with different steel fiber content were determined by three-point bending tests and double-K fracture criterion. The results show that the content of steel fiber is an important factor that influences the fracture toughness of high performance concrete. The fracture toughness of high performance concrete increases with the increasing of steel fiber content, and the average fracture toughness of concrete with steel fiber content of 2% and 4% is 9.5 and 10.6 times to the content of 0 respectively. In the fixed matrix concrete mix ratio conditions, the compressive strength, fluidity, and fracture toughness of high performance concrete are optimized with the steel fiber content of 2%.
关键词:
高性能钢纤维混凝土;钢纤维掺量;断裂韧性;力学性能
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加
(1)混凝土单边切口梁的3点弯曲试验表明,钢纤维的加入可以有效提高高性能混凝土的断裂韧性,并且在0~4%范围内,随着钢纤维掺量的增加,混凝土的断裂韧性得到显著改善,钢纤维掺量为2%和4%的混凝土断裂韧度平均值分别是不掺量钢纤维混凝土的9.5倍和10.6倍。
(2)在0~4%范围内,随着钢纤维掺量的增加,试件的最大破坏荷载、破坏挠度以及裂缝嘴张开位移逐渐增加,P-S曲线和P-CMOD曲线越来越圆滑、饱满,断裂能随纤维掺量的增加而增长。
(3)在0~4%范围内,随着钢纤维掺量的增加,混凝土的抗弯强度逐渐增加,但抗压强度及流动性都有下降趋势,有效裂缝长度先增加后减小。
(4)结合单边切口梁3点弯曲断裂韧度的评定可知,在固定基质混凝土配合比条件下,钢纤维掺量为2%时,钢纤维高性能混凝土各项性能到达最优。
[1] 冯乃谦.高性能混凝土与超高性能混凝土的发展和应用[J].施工技术,2009(4):1-6.
[2] 周履.高性能混凝土(HPC)发展的综合评述[J].建筑结构,2004(6):65-72.
[3] Hájek P, Fiala C, Lup?觔?魣iEk A. High Performance Concrete for Environmentally Efficient Building Structures[J].Key Engine ering Materials,2016,691:272-284.
[4] 郑建岚,罗素蓉,王雪芳.高性能混凝土抗裂性能研究[J].工程力学,2008(S2):71-98.
[5] Jeng F,Lin M L,Yuan S C. Performance of Toughness Indices for Steel Fiber Reinforced Shotcrete[J]. Tunneling and Underground Space Technology,2002,17(1):69-82.
[6] 王德辉,史才军,吴林妹.超高性能混凝土在中国的研究和应用[J].硅酸盐通报,2016(1):141-149.
[7] 邓宗才.混杂纤维增强超高性能混凝土弯曲韧性与评价方法[J].复合材料学报,2016(6):1274-1280.
[8] 赵顺波,孙晓燕,李长永,等.高强钢纤维混凝土弯曲韧性试验研究[J].建筑材料学报,2003(1):95-99.
[9] 朱海堂,高丹盈,谢丽,等.钢纤维高强混凝土弯曲韧性的试验研究[J].硅酸盐学报,2004,32(5):656-660.
[10] Sovják R,,Máca P,Imlauf T. Effect of fibre aspect ratio and fibre volume fraction on the effective fracture energy of ultra-high-performance fibre-reinforced concrete[J].2016,56(4):319-327.
[11] Kang S T,Yun L,Park Y D,et al.Tensile fracture properties of an Ultra High Performance Fiber Reinforced Concrete (UHPFRC) with steel fiber[J]. Composite Structures,2010,92(1):61-71.
[12] Holschemacher K,Mueller T,Ribakov Y. Effect of steel fibres on mechanical properties of high-strength concrete[J]. Materials & Design,2010,31(5):2604-2615.
[13] 赵亮平,高丹盈,朱海堂.钢纤维对混凝土强度和韧性的影响[J].华北水利水电学院学报,2012(6):29-32.
[14] 朱海堂.钢纤维高强混凝土的断裂韧性及缺口敏感性研究[J].四川建筑科学研究,2009(3):173-176.
[15] 胡若邻,黄培彦.钢纤维增强聚合物改性高强混凝土断裂韧性的试验研究[J].应用基础与工程科学学报,2011(6):963-970.
[16] 徐世烺.混凝土断裂试验与断裂韧度测定标准方法[M].北京:机械工业出版社,2009.
[17] 程秀菊,朱为玄.钢纤维混凝土KIC计算公式初探[J].河海大学学报:自然科学版,2005,33(4):452-454.
[18] 张廷毅,高丹盈,朱海堂.钢纤维高强混凝土的断裂韧度[J].建筑材料学报,2007(5):577-582.

丁亚红,马金一,徐平,.钢纤维含量对高性能混凝土断裂性能影响的试验研究及评价分析[J].混凝土与水泥制品,2018(2):50-54.

DING Y H,MA J Y,XU P,et al.Experimental Study and Evaluation Analysis on Influence of Steel Fiber Content on Toughness Properties of High Performance Concrete[J].China Concrete and Cement Products,2018(2):50-54.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州