苏州混凝土水泥制品研究院有限公司

头部文案

发布时间:2020-01-06 00:00:00
全国建材科技期刊
全国中文核心期刊
中国科技论文统计源期刊
万方数据-数字化期刊群入网期刊
中国学术期刊(光盘版)全文收录期刊
华东地区优秀科技期刊
江苏省期刊方阵“双效期刊”
中国期刊网全文收录期刊
中国科技期刊数据库全文收录期刊
钢结构楼板泵送轻骨料混凝土优化配比研究
Optimal Mix Proportion Study on Pumping Lightweight Aggregate Concrete for Floor Slabs with Steel Structure
2016年第10期
泵送轻骨料混凝土;配合比设计;干密度;优化分析
Pumping light weight aggregate concrete; Mix design; Dry density; Optimization analysis
2016年第10期
1000-4637(2016)10-56-06
北京市自然科学基金项目(8142012);北京建筑大学科学研究基金项目(00331616027)
焦立颖
北京恒坤混凝土有限公司,102300

焦立颖

浏览量:
1000
摘 要:对中高层钢结构建筑楼顶板所需要的泵送轻骨料混凝土进行了优化配比研究,对已有轻骨料混凝土配比在运用过程中的特点及不足进行了分析。从优选原材料入手,对本工程混凝土配合比进行了设计及优化,得到了低密度泵送轻骨料混凝土。试验结果表明,此配比下的轻骨料混凝土力学性能、体积稳定性等均满足规范和工程要求。研究成果为同类建筑结构、大跨径桥梁建设的泵送轻骨料混凝土及要求减轻结构自重的工程提供了参考。 Abstract: The mix ratio of pumping light weight aggregate concrete needed for middle and high rise steel structure building roof board is studied. The characteristics and deficiencies of the existing light weight aggregate concrete in the application process are analyzed, according to the optimization of raw materials, the design and optimization of concrete mix ratio of this project was carried out, finally the low density pumping light weight aggregate concrete was prepared. The results show that the mechanical properties and the volume stability of lightweight aggregate concrete under this ratio meet the requirements of the specification and the engineering need. The research results provide an important choice for the construction of similar structures and large span bridges, the pumping light aggregate concrete and the requirement of reducing the weight of the structure.
英文名 : Optimal Mix Proportion Study on Pumping Lightweight Aggregate Concrete for Floor Slabs with Steel Structure
刊期 : 2016年第10期
关键词 : 泵送轻骨料混凝土;配合比设计;干密度;优化分析
Key words : Pumping light weight aggregate concrete; Mix design; Dry density; Optimization analysis
刊期 : 2016年第10期
DOI :
文章编号 : 1000-4637(2016)10-56-06
基金项目 : 北京市自然科学基金项目(8142012);北京建筑大学科学研究基金项目(00331616027)
作者 : 焦立颖
单位 : 北京恒坤混凝土有限公司,102300

焦立颖

摘要
参数
结论
参考文献
引用本文

摘   要:对中高层钢结构建筑楼顶板所需要的泵送轻骨料混凝土进行了优化配比研究,对已有轻骨料混凝土配比在运用过程中的特点及不足进行了分析。从优选原材料入手,对本工程混凝土配合比进行了设计及优化,得到了低密度泵送轻骨料混凝土。试验结果表明,此配比下的轻骨料混凝土力学性能、体积稳定性等均满足规范和工程要求。研究成果为同类建筑结构、大跨径桥梁建设的泵送轻骨料混凝土及要求减轻结构自重的工程提供了参考。

Abstract: The mix ratio of pumping light weight aggregate concrete needed for middle and high rise steel structure building roof board is studied. The characteristics and deficiencies of the existing light weight aggregate concrete in the application process are analyzed, according to the optimization of raw materials, the design and optimization of concrete mix ratio of this project was carried out, finally the low density pumping light weight aggregate concrete was prepared. The results show that the mechanical properties and the volume stability of lightweight aggregate concrete under this ratio meet the requirements of the specification and the engineering need. The research results provide an important choice for the construction of similar structures and large span bridges, the pumping light aggregate concrete and the requirement of reducing the weight of the structure.

关键词:
泵送轻骨料混凝土;配合比设计;干密度;优化分析
扫二维码用手机看
未找到相应参数组,请于后台属性模板中添加

(1)以600级页岩陶粒、700级陶砂为轻骨料,在配制干表观密度小于1500kg/m3的C25配合比设计中,轻骨料的密度等级、陶砂与河砂的比例是控制轻骨料混凝土密度的关键因素。

(2)在初步配合比试拌的基础上,陶砂与河砂的比例由5∶5调整至8∶2,有效地降低了轻骨料混凝土的密度,另外掺加具有引气作用、少量增黏作用的泵送剂是改善轻骨料混凝土密度及可泵性的有效措施。

(3)轻骨料含水率对混凝土的收缩影响很大,尤其是早期收缩。轻骨料的吸水率越大,混凝土的收缩越小。因此,轻骨料混凝土在生产前,需对轻骨料进行饱和吸水处理。
(4)轻骨料混凝土的饱和吸水预湿环节非常重要,可以使混凝土拌合物在泵送压力下尽可能少地吸入水分,从而提高轻骨料混凝土的泵送性能。
[1] 杨秋玲,马克栓. 轻骨料混凝土的现状与发展[J].铁道建筑,2006(6):73-75.
[2] Melby K, JordetE A, HansvoldC. Long-span bridges in Norway constructed in high-strength LWA conrete [J]. Engineering Structures, 1996, 18(11): 845-849.
[3] 王海亮,景凌,陈小龙,等.干密度小于1400kg/m3轻骨料混凝土长距离泵送[C].混凝土低碳技术与高性能混凝土——混凝土低碳技术国际学术研讨会暨第九届全国高性能混凝土学术研讨会论文选编,2010:366-369.
[4] 陈烈芳,李荣,宋淑敏.轻骨料混凝土工程应用案例.轻骨料工业发展及工程应用[C].第十一届全国轻骨料及轻骨料混凝土学术讨论会暨第五届海峡两岸轻骨料混凝土产制与应用技术研讨会论文集,2012:216-234. 
[5] 王国荣.100米高强泵送陶粒混凝土的应用(滨江国际花园陶粒混凝土的应用)[C].“第八届全国轻骨料及轻骨料混凝土学术讨论会”暨“第二届海峡两岸轻骨料混凝土产制与应用技术研讨会”论文集,2006:291-299. 
[6] 季永新,杨景饶,朱伯庆,等.南京太阳宫广场戏水大厅屋顶拱梁轻质陶粒混凝土应用及施工[C]. “第七届全国轻骨料混凝土学术讨论会”暨“第一届海峡两岸轻骨料混凝土产制与应用技术研讨会”论文集,2004,381-391. 
[7] 胡曙光,王发洲.轻集料混凝土[M].北京:中国化学工业出版社,2006.
[8] 龚洛书.国内外轻骨料混凝土配合比设计方法评述[J].建筑技术,1991,18(8):48-52.
[9] JA Bogas,A Gomes. A simple mix design method for structural lightweight aggregate concrete[J].Materials and Structures,2013,46(11):1919-1932.
[10] 董淑慧,葛勇,袁杰,等. 轻骨料混凝土的收缩性能研究[J].混凝土,2008(2):47-49.
[11] 宋培晶,丁建彤,郭玉顺.高强轻骨料混凝土的收缩及其影响因素的研究[J].建筑材料学报,2004,7(2):138-144.
[12] 应小洋.泵送轻骨料混凝土的研究[J].浙江建筑,2006(2):50-52.

相关文件

暂时没有内容信息显示
请先在网站后台添加数据记录。

关注《混凝土与水泥制品》

总访问量 468,401   网站统计

官方微信公众号关闭
苏州混凝土水泥制品研究院有限公司

关于我们    |    联系我们    |    订购杂志    |    回到顶部

版权所有:中国混凝土与水泥制品网  苏ICP备10086386号   网站建设:中企动力 苏州

版权所有:中国混凝土与水泥制品网

苏ICP备10086386号

网站建设:中企动力 苏州